YOUNGSTOWN, OHIO—
Industrial Mill Maintenance Inc
Fall or jump curtailed by personal fall arrest system · Fractures
Final narrative
An employee was descending from a ladder into a railcar. He pulled his retractable lifeline out so when he hopped down the last step, the automatic stopping mechanism would not engage on his personal fall arrest system. When he jumped, the arrest system still engaged and pulled his body back, causing him to land on and twist his right foot. His right ankle broke and required surgery.
Similar incidents · Same event type
TEMPLE, TEXAS—
Peabody General Contractors
An employee was walking along a trench inspecting the trench box in the excavation when he tripped and fell toward the trench. As the employee was falling head-first into the trench, he attempted to get a hold of the fall protection cable. The cable then looped around his left hand and the employee fell approximately 8 feet into the trench before the fall protection engaged. The employee suffered amputations of his left index, middle, ring, and little fingers.
MOOSE, WYOMING—
National Park Service
A ranger was performing back-country patrol duties while hiking. As they were climbing a technical rock patch, a rock handhold broke, causing the employee to fall approximately 15 feet before their belay engaged. The employee contacted a rock, resulting in a fracture to the right ilium as well as a subcutaneous hematoma to the right gluteal region.
LITTLE ROCK, ARKANSAS—
Lexicon, Inc.
Employees were erecting structural steel. The injured employee was sitting on a 12" wide horizontal member and lining up an I-beam brace as it was suspended by an overhead crane. He leaned left to push the end of the brace. The end of the suspended brace swung away from him, causing him to lose balance and fall 8 feet. His personal fall arrest system arrested his fall, but he swung into a piece of duct work during the fall that resulted in a concussion.
TALLAHASSEE, FLORIDA—
Rapid Building Solutions, LLC
On September 12, 2022, an employee was on a metal roof, installing a standing seam and insulation. He lost his balance and fell toward the third floor slab, which was 10 feet from the roof. His fall protection caught him and left him suspended about 2 to 4 feet from the slab. He suffered a brain bleed and a spinal fracture in his lower back. He was hospitalized.
HOT SPRINGS, ARKANSAS—
West Tree Service, Inc.
An employee was working from a bucket lift, removing a tree in sections. He lost his balance while pushing on a section and fell. His fall protection caught him and he swung into a tree, suffering an injury that caused head, neck, and leg pain, as well as loss of consciousness while he was at the hospital.