OSHA Inspection: CATALYST CARD CO.

Issued

2016-07-29 00:00:00

Penalty

Initial $1785.00 · Current $900.00 Reduced

General-duty citation text

29 CFR 1910.242(b): Compressed air used for cleaning purposes was not reduced to less than 30 p.s.i.:    (a) On or about July 5,2016, the employees were exposed to flying chips and other forced-air hazards from an air compressor that was set at approximately 120 p.s.i. which was used for blowing down part in the chip room.       Abatement Note: Abatement certification is required for this item (see enclosed "Certification of Corrective Action Worksheet").

Issued

2016-07-29 00:00:00

Abate by

2016-08-17 00:00:00

Penalty

Initial $3500.00 · Current $1800.00 Reduced

General-duty citation text

29 CFR 1910.178(q)(7): Industrial trucks were being placed in services after the examination showed condition(s) adversely affecting the safety of the vehicle:      On or about July 5, 2016, employees were exposed to struck-by hazards due to the 15 Komatsu Forklift, being placed into service after the forklift hydraulic leaks were found.    Abatement Note: Abatement certification is required for this item (see enclosed "Certification of Corrective Action Worksheet").

Issued

2016-07-29 00:00:00

Abate by

2016-08-17 00:00:00

Penalty

Initial $0.00 · Current $0.00

General-duty citation text

29 CFR 1910.1200(f)(6)(ii): Except as provided in 29 CFR 1910.1200(f)(7) and 29 CFR 1910.1200(f)(8), the employer did not ensure that each container of hazardous chemicals in the workplace was labeled, tagged or marked with the product identifier and words, pictures, symbols, or combination thereof, which provide at least general information regarding the hazards of the chemicals and which, in conjunction with the other information immediately available to employees under the hazard communication program, would provide employees with the specific information regarding the physical and health hazards of the hazardous chemical:  (a)  On or about July 5, 2016, employees were exposed to a container of hazardous chemical that was not labeled, including but not limited, a container of MagniTek Y-120 Wash.    Abatement Note:  Abatement certification and documentation are required for this item (see enclosed "Certification of Corrective Action Worksheet").

Issued

2016-07-29 00:00:00

Abate by

2016-08-17 00:00:00

Penalty

Initial $0.00 · Current $0.00

General-duty citation text

29 CFR 1910.303(g)(1): Sufficient access and working space was not provided and maintained about all electric equipment (operating at 600 volts, nominal, or less to ground) to permit ready and safe operation and maintenance of such equipment:  a) On or about July 5, 2016, the employer did not maintain a clear distance 3 feet in front of the circuit breaker panels in that the electrical panels were not accessible preventing emergency shutdown, electrical repairs and maintenance.    Abatement Note: Abatement certification and documentation are required for this item (see enclosed "Certification of Corrective Action Worksheet").