OSHA Inspection: CHAMPION ROOFING CORP.

Issued

2018-07-30 00:00:00

Abate by

2018-08-03 00:00:00

Penalty

Initial $3880.00 · Current $2900.00 Reduced

General-duty citation text

OSH ACT of 1970 Section (5)(a)(1): The employer did not furnish employment and a place of employment which were free from recognized hazards that were causing or likely to cause death or serious physical harm to employees in that employees were exposed to a potential fall hazard of twenty-two (22) feet from a roof to ground level.    a) Roof, 65 Broadway Street, Milton, PA - Employees worked on the steep-sloped (14:12 pitch) roof of a commercial establishment and used a Climbing Technology Quick'Up Plus Rope Ascender as part of a personal fall arrest system which was not being used in accordance with the manufacturer's instructions and industry standards exposing the employees to a twenty-two (22) foot fall hazard, on or about May 3, 2018.    In accordance with 29 CFR 1903.19, abatement documentation and certification is required for this violation.

Issued

2018-07-30 00:00:00

Abate by

2018-08-03 00:00:00

Penalty

Initial $0.00 · Current $0.00

General-duty citation text

29 CFR 1926.501(b)(11): Each employee on a steep roof with unprotected sides and edges 6 feet (1.8 m) or more above lower levels was not protected from falling by guardrail systems with toeboards, safety net systems, or personal fall arrest systems.  a) 65 Broadway Street, Milton, PA - Employees worked on the steep-sloped (14:12 pitch) roof of a commercial establishment without any means of fall protection and were exposed to a twenty-two (22) foot fall hazard, as observed on or about May 3, 2018.  In accordance with 29 CFR 1903.19, abatement certification and documentation is required for this violation.

Issued

2018-07-30 00:00:00

Abate by

2018-08-03 00:00:00

Penalty

Initial $0.00 · Current $0.00

General-duty citation text

29 CFR 1926.502(d)(17): The attachment point of the body harness was not located in the center of the wearer's back near shoulder level, or above the wearer's head:  a) 65 Broadway Street, Milton, PA - Employees worked on the steep-sloped (14:12 pitch) roof of a commercial establishment with a rope attached by a rope ascender and carabiner to the ventral (waist) attachment point of a body harness and were exposed to blunt force trauma hazards in the event of a fall, as observed on or about May 3, 2018.  In accordance with 29 CFR 1903.19, abatement certification and documentation is required for this violation.

Issued

2018-07-30 00:00:00

Abate by

2018-08-13 00:00:00

Penalty

Initial $0.00 · Current $0.00

General-duty citation text

29 CFR 1926.503(a)(1): The employer did not provide a training program for each employee potentially exposed to fall hazards to enable each employee to recognize the hazards of falling and the procedures to be followed in order to minimize these hazards:  a) Roof, 65 Broadway Street, Milton, PA - Employees that worked on a twenty-two (22) foot high roof above ground level without any means of fall protection lacked the training to recognize or minimize the fall hazard, as observed on or about May 4, 2018.  b)  Roof, 65 Broadway Street, Milton, PA - Employees worked on a twenty-two (22) foot high roof above ground level with a rope attached to the ventral (waist) attachment point of a harness lacked the training to recognize and minimize the blunt force trauma hazard that was created, as observed on or about May 4, 2018.  In accordance with 29 CFR 1903.19, abatement certification and documentation is required for this violation.

Issued

2018-07-30 00:00:00

Abate by

2018-08-03 00:00:00

Penalty

Initial $2772.00 · Current $2080.00 Reduced

General-duty citation text

29 CFR 1926.1053(b)(1): Where portable ladders were used for access to an upper landing surface and the ladder's length allows, the ladder side rails did not extend at least 3 feet (.9 m) above the upper landing surface being accessed.    a) East Roof Edge, 65 Broadway Street, Milton, PA - Employees used a Werner 28-foot aluminum extension ladder for roof access/egress with side rails that extended twenty (20) inches above the top of the roof edge exposing the employees to a twenty-two (22) foot fall hazard, as observed on or about May 3, 2018.    b) South Roof Edge, 65 Broadway Street, Milton, PA - Employees used a Werner 28-foot aluminum extension ladder for roof access/egress with side rails that extended eight (8) inches above the top of the roof edge exposing the employees to a twenty-two (22) foot fall hazard, as observed on or about May 3, 2018.    In accordance with 1903.19, abatement documentation and certification required for this violation.

Issued

2018-07-30 00:00:00

Abate by

2018-08-17 00:00:00

Penalty

Initial $0.00 · Current $0.00

General-duty citation text

29 CFR 1926.102(a)(1): Eye and face protective equipment were not used when machines or operations presented potential eye or face injury from physical, chemical, or radiation agents.  a) Roof, 65 Broadway Street, Milton, PA - Employees were not wearing eye protection while using a nail gun to attach shingles to the roof and were exposed to potential eye injuries, as observed on or about May 3, 2018.  In accordance with 29 CFR 1903.19, abatement certification is required for this violation.