OSHA Inspection: MEMORIAL MONUMENTS & VAULTS, INC.

Issued

2022-04-07 00:00:00

Penalty

Initial $13052.00 · Current $10000.00 Reduced

General-duty citation text

29 CFR  1910.106(e)(2)(ii)(b): The quantity of liquid that may be located outside of an inside storage room or storage cabinet in a building or in any one fire area of a building shall not exceed:  (1)  25 gallons of Category 1 flammable liquids in containers (2)  120 gallons of Category 2, 3, or 4 flammable liquids in containers (3)  660 gallons of Category 2, 3, or 4 flammable liquids in a single portable tank.  (a)	On February 8, 2022 and times prior, at or near 300 Mandan Avenue in Mandan, North Dakota, for the employee exposed to fire hazards where flammable liquids exceeding acceptable quantity limits, are stored in cabinets not meeting the requirements to be classified as flammable liquid storage. -

Issued

2022-04-07 00:00:00

Penalty

Initial $13052.00 · Current $10000.00 Reduced

General-duty citation text

29 CFR  1910.179(j)(3):Complete inspections of the crane was not being performed at intervals as generally defined in paragraph (j)(1)(ii)(b) of this section:  (a)	On February 8, 2022 and times prior, at or near 300 Mandan Avenue in Mandan, North Dakota, for the employee exposed to crushing hazards where overhead gantry cranes utilized for lifting operations were not inspected periodically by a person meeting the definition of a competent person to ensure the safe operation of the cranes.

Issued

2022-04-07 00:00:00

Abate by

2022-04-19 00:00:00

Penalty

Initial $0.00 · Current $0.00

General-duty citation text

29 CFR  1910.184(c)(1):Sling(s) that were damaged or defective were used:  (a)	On February 8, 2022 and times prior, at or near 300 Mandan Avenue in Mandan, North Dakota, for the employee exposed to crushing hazards where synthetic web sling used to lift the concrete hopper and the quad leg lifting device did not have the required safety latch.

Issued

2022-04-07 00:00:00

Abate by

2022-04-19 00:00:00

Penalty

Initial $0.00 · Current $0.00

General-duty citation text

29 CFR  1910.184(f)(5)(i):Wire rope sling(s) that had ten or more randomly distributed broken wires in one rope lay, or five or more broken wires in one strand in one rope lay, were not immediately removed from service:  (a)	On February 8, 2022 and times prior, at or near 300 Mandan Avenue in Mandan, North Dakota, for the employee exposed to crushing hazards where wire rope lifting slings had more than the allowable broken wire strands in one rope lay.

Issued

2022-04-07 00:00:00

Abate by

2022-05-24 00:00:00

Penalty

Initial $1047.00 · Current $418.00 Reduced

General-duty citation text

29 CFR  1910.243(c)(1):Abrasive wheel(s) were used on portable grinder(s) which were not provided with safety guard(s) meeting the requirements specified in 29 CFR 1910.243(c)(1) through (c)(4)of this section:  (a)	On February 8, 2022 and times prior, at or near 300 Mandan Avenue in Mandan, North Dakota, for the employee exposed to injury from flying debris where a Milwaukee angle grinder did not have the required guard attached.

Issued

2022-04-07 00:00:00

Abate by

2022-05-24 00:00:00

Penalty

Initial $1047.00 · Current $418.00 Reduced

General-duty citation text

29 CFR  1910.254(d)(9)(iii):Cables with damaged insulation or exposed bare conductors were not replaced:  (a)	On February 8, 2022 and times prior, at or near 300 Mandan Avenue in Mandan, North Dakota, for the employee exposed to electrical shock hazards where the welder lead sheathing was split open near the welding gun handle.

Issued

2022-04-07 00:00:00

Abate by

2022-05-24 00:00:00

Penalty

Initial $0.00 · Current $0.00

General-duty citation text

29 CFR  1910.334(a)(2)(ii):There was a defect or evidence of damage that could have exposed an employee to injury and the defective or damaged item was not removed from service:  (a)	On February 8, 2022 and times prior, at or near 300 Mandan Avenue in Mandan, North Dakota, for the employee exposed to electrical shock hazards where a plug and cord set that was damaged was not taken out of service.

Issued

2022-04-07 00:00:00

Abate by

2022-05-24 00:00:00

Penalty

Initial $1047.00 · Current $418.00 Reduced

General-duty citation text

29 CFR  1910.1200(g)(1):Employers did not have a safety data sheet in the workplace for each hazardous chemical which they use:  (a)	On February 8, 2022 and times prior, at or near 300 Mandan Avenue in Mandan, North Dakota, for the employee exposed to chemical hazards where the employer did not provide the Safety Data Sheets which provides critical information for the safe handling and use of the chemicals at the facility.

Issued

2022-04-07 00:00:00

Abate by

2022-05-24 00:00:00

Penalty

Initial $1047.00 · Current $418.00 Reduced

General-duty citation text

29 CFR  1910.1200(h)(1):Employees were not provided effective information and training on hazardous chemicals in their work area at the time of their initial assignment and whenever a new hazard that the employees had not been previously trained about was introduced into their work area:  (a)	On February 8, 2022 and times prior, at or near 300 Mandan Avenue in Mandan, North Dakota, for the employee exposed to chemical hazards where the employer failed to train employees of the hazards associated with the chemicals that they are required to handle and use in the performance of their job duties.