LOUISBURG, NC —
OSHA Inspection: QUALITY PRECAST, INC.
Complaint inspection · Health discipline
At a glance
On , OSHA opened a complaint health inspection of QUALITY PRECAST, INC. in 100 GAYLINE DRIVE, LOUISBURG, NC 27549 (NAICS 327390). OSHA activity number 310040613.
OSHA opens inspections for many reasons — routine scheduling under a national or local emphasis program, an employee complaint or referral, or a follow-up after a reported injury. Opening or conducting an inspection is not itself an allegation or a finding that this employer broke any rule; any findings appear as the citations listed below, and citations can be contested, reduced, or withdrawn.
Where did this inspection happen?
- Establishment
- QUALITY PRECAST, INC.
- Site address
- 100 GAYLINE DRIVE
- City
- LOUISBURG
- State
- NC
- ZIP
- 27549
- Mailing
- P.O. BOX 580, FRANKLINTON, NC 27525
What kind of inspection was it?
- Inspection type
- Complaint (B)
- Scope
- Partial (B)
- Discipline
- Health
- Advance notice
- No
- Union status
- N
When did the case open and close?
- Opened
- Closing conference
- Case closed
- Last modified
- Data loaded
Establishment context
- NAICS code
- 327390
- SIC code (legacy)
- 3272
- Employees
- 9
- Ownership type
- A
- Industry flags
- Manufacturing health.
Citations
13 citations on file for this inspection.
95012901
- Issued
- Oct 17, 2006
- Abate by
- Oct 20, 2006
- Penalty
- Initial $350 · Current $263 Reduced
General-duty citation text
North Carolina General Statute 95-129(1) of the Occupational Safety and Health Act of North Carolina: The employer did not furnish each of his employees conditions of employment and a place of employment free from recognized hazards that were causing or likely to cause death or serious physical harm to employees in that employees were exposed to struck by hazards: a)facility - where the employees were allowed to work in close proximity to an overheard underhung crane that was used to lift batteries of concrete counter weights up to approximately 1100 pounds without a safety retainer installed on the hook. One feasible and acceptable abatement method, among other, to correct this hazard is to install a safety retainer or replace the hook. (Reference: American Society of Mechanical Engineers, for Overhead Hoists (underhung), ASME B30.16-1993, Chapter 16-1 (Marking, Construction, and Installation), Section 16-1.2 (Construction), Section 16-1.2.1(a) (Mechanical Design).cal
Recent events (2)
- — I (S) $263.00
- — Z (S) $350.00
95012901
- Issued
- Oct 17, 2006
- Abate by
- Oct 20, 2006
- Penalty
- Initial $350 · Current $263 Reduced
General-duty citation text
North Carolina General Statute 95-129(1) of the Occupational Safety and Health Act of North Carolina: The employer did not furnish each of his employees conditions of employment and a place of employment free from recognized hazards that were causing or likely to cause death or serious physical harm to employees in that employees were exposed to throw against, struck by and crushed by Roll Over Protection System (ROPS) hazard during tip-over: a)facility - for an employee observed operating a Hyster Forklift truck (Model 65) without wearing the installed seat belt during operation. One feasible and acceptable abatement method, among other, to correct this hazard is to have operators fasten the seat belt while operating equipment. (Reference: ASME B56-1-1993, Paragraph5.3.19: An active operator protection device or system, when provided, shall be used.)
Recent events (2)
- — I (S) $263.00
- — Z (S) $350.00
1910.147 C01
- Issued
- Oct 17, 2006
- Abate by
- Dec 5, 2006
- Penalty
- Initial $350 · Current $263 Reduced
Recent events (2)
- — I (S) $263.00
- — Z (S) $350.00
1910.147 C04 I
- Issued
- Oct 17, 2006
- Abate by
- Oct 20, 2006
Recent events (2)
- — I (S)
- — Z (S)
1910.147 C07 I
- Issued
- Oct 17, 2006
- Abate by
- Nov 13, 2006
Recent events (2)
- — I (S)
- — Z (S)
1910.212 A01
- Issued
- Oct 17, 2006
- Abate by
- Oct 20, 2006
- Penalty
- Initial $350 · Current $263 Reduced
Recent events (2)
- — I (S) $263.00
- — Z (S) $350.00
1910.132 D02
- Issued
- Oct 17, 2006
- Abate by
- Nov 13, 2006
Recent events (2)
- — I (O)
- — Z (O)
1910.134 C02 I
- Issued
- Oct 17, 2006
- Abate by
- Nov 13, 2006
Recent events (2)
- — I (O)
- — Z (O)
1910.145 F03
- Issued
- Oct 17, 2006
- Abate by
- Oct 20, 2006
Recent events (2)
- — I (O)
- — Z (O)
1910.157 C01
- Issued
- Oct 17, 2006
- Abate by
- Oct 20, 2006
Recent events (2)
- — I (O)
- — Z (O)
1910.1200 E01
- Issued
- Oct 17, 2006
- Abate by
- Dec 5, 2006
Recent events (2)
- — I (O)
- — Z (O)
1910.1200 G08
- Issued
- Oct 17, 2006
- Abate by
- Oct 20, 2006
Recent events (2)
- — I (O)
- — Z (O)
1910.1200 H01
- Issued
- Oct 17, 2006
- Abate by
- Nov 13, 2006
Recent events (2)
- — I (O)
- — Z (O)
More inspections at Quality Precast, INC.
View Quality Precast, INC.'s full OSHA safety record →
More inspections in this industry (NAICS 327390)
More inspections in NC
Source
This record is reproduced from the U.S. Department of Labor Open Data API (OSHA inspection dataset). The original IMIS detail view is available at OSHA's Establishment Search for activity number 310040613.
Look up any company's OSHA accident reports by company, or browse severe injury reports by year, state, and company.