FREDERICK, MD —
OSHA Inspection: DAIRY MAID DAIRY INC
Referral inspection · Health discipline
At a glance
On , OSHA opened a referral health inspection of DAIRY MAID DAIRY INC in 259 EAST 7TH STREET, FREDERICK, MD 21701 (NAICS 311511). OSHA activity number 316260116.
OSHA opens inspections for many reasons — routine scheduling under a national or local emphasis program, an employee complaint or referral, or a follow-up after a reported injury. Opening or conducting an inspection is not itself an allegation or a finding that this employer broke any rule; any findings appear as the citations listed below, and citations can be contested, reduced, or withdrawn.
Where did this inspection happen?
- Establishment
- DAIRY MAID DAIRY INC
- Site address
- 259 EAST 7TH STREET
- City
- FREDERICK
- State
- MD
- ZIP
- 21701
What kind of inspection was it?
- Inspection type
- Referral (C)
- Scope
- Partial (B)
- Discipline
- Health
- Advance notice
- No
- Union status
- N
When did the case open and close?
- Opened
- Closing conference
- Case closed
- Last modified
- Data loaded
Establishment context
- NAICS code
- 311511
- SIC code (legacy)
- 2026
- Employees
- 102
- Ownership type
- A
Citations
12 citations on file for this inspection.
1910.134 C01
- Issued
- Jul 19, 2012
- Abate by
- Sep 4, 2012
- Penalty
- Initial $1,875 · Current $1,100 Reduced
Recent events (2)
- — I (S) $1100.00
- — Z (S) $1875.00
1910.134 D03 IIIB2
- Issued
- Jul 19, 2012
- Abate by
- Jul 27, 2012
Recent events (2)
- — I (S)
- — Z (S)
1910.134 F01
- Issued
- Jul 19, 2012
- Abate by
- Jul 27, 2012
Recent events (2)
- — I (S)
- — Z (S)
1910.134 K01
- Issued
- Jul 19, 2012
- Abate by
- Jul 19, 2012
Recent events (2)
- — I (S)
- — Z (S)
1910.146 C04
- Issued
- Jul 19, 2012
- Abate by
- Sep 4, 2012
- Penalty
- Initial $2,250 · Current $1,300 Reduced
Recent events (2)
- — I (S) $1300.00
- — Z (S) $2250.00
1910.146 G01
- Issued
- Jul 19, 2012
- Abate by
- Sep 4, 2012
Recent events (2)
- — I (S)
- — Z (S)
50104 A
- Issued
- Jul 19, 2012
- Abate by
- Jul 27, 2012
- Penalty
- Initial $2,625 · Current $1,100 Reduced
General-duty citation text
Labor and Employment Article, Section 5-104(a): The employer did not furnish employment and a place of employment which were free from recognized hazards that were causing or likely to cause death or serious physical harm to employees: (a)Date of Violation:03/07/12 Condition:Employees were not adequately protected against the potential release of anhydrous ammonia in that: A) On or About 03/07/12 All piping (main, headers, and branches) were not properly labeled; B) On or About 03/07/12 The machine room was not effectively sealed off from other areas of the plant, including a lack of tight seals where piping penetrated wall, spaces, and/or ceilings; C) On or About 03/07/12 The emergency shut off switch was not located in an area separated from the machine room by a fire rated door; D) On or About 03/07/12 The control for the emergency ventilation was not located outside of the machine room; E) On or About 03/07/12 pressure relief valves were not replaced every five years nor were they labeled with their in-service dates; F) On or About 03/07/12 piping and valves, including the Pressure relief valves, were not labeled; G) On or About 03/07/12 The discharge pipe was not located at least 15 feet above any adjacent grades or roof levels; H) On or About 03/07/12 Potentially flammable and combustible materials were stored within the machine room; I) On or About 03/07/12 Ammonia detectors had not been calibrated and maintained according to the manufacturers recommendations; J) On or About 03/07/12 Calculations were not available to verify that the discharge piping from each pressure relief valve was sized appropriately; K) On or About 03/07/12 That the ventilation provided the appropriate number of air changes per hour, or that the emergency ventilation would provide the appropriate number of air changes per hour; L) On or About 03/07/12 Written emergency shut down procedures had not been developed; M) On or About 03/07/12 Corrosion and vibration testing had not been conducted; and, N) On or About 03/07/12 an eyewash station was not found working in an adjacent room. Among other methods, one feasible and acceptable method to correct this hazard is to comply with industry recognized and generally accepted good engineering practices including, but not limited to, those consensus standards published by the American Society of Heating, Refrigerating and Air-Conditioning Engineers (ASHRAE), American National Standards Institute (ANSI), and the International Institute of Ammonia Refrigeration (IIAR). Abatement documentation (photographs, receipts, copies of programs, training certification, etc.) is required for this item.
Recent events (2)
- — I (S) $1100.00
- — Z (S) $2625.00
1910.95 C01
- Issued
- Jul 19, 2012
- Abate by
- Sep 4, 2012
81108111
Recent events (2)
- — I (O)
- — Z (O)
1910.134 C03
- Issued
- Jul 19, 2012
- Abate by
- Jul 19, 2012
Recent events (2)
- — I (O)
- — Z (O)
1910.134 E01
- Issued
- Jul 19, 2012
- Abate by
- Jul 19, 2012
Recent events (2)
- — I (O)
- — Z (O)
1910.134 H02 I
- Issued
- Jul 19, 2012
- Abate by
- Jul 27, 2012
Recent events (2)
- — I (O)
- — Z (O)
1910.146 G04
- Issued
- Jul 19, 2012
- Abate by
- Jul 27, 2012
Recent events (2)
- — I (O)
- — Z (O)
More inspections at Dairy Maid Dairy INC
View Dairy Maid Dairy INC's full OSHA safety record →
More inspections in this industry (NAICS 311511)
More inspections in MD
Source
This record is reproduced from the U.S. Department of Labor Open Data API (OSHA inspection dataset). The original IMIS detail view is available at OSHA's Establishment Search for activity number 316260116.
Look up any company's OSHA accident reports by company, or browse severe injury reports by year, state, and company.