OSHA Inspection: CARDINAL ROOFING

Issued

Jun 6, 2012

Abate by

Jun 7, 2012

Penalty

Initial $2,000 · Current $1,000 Reduced

General-duty citation text

29 CFR 1926.20(b)(2):     Such programs shall provide for frequent and regular inspections of the job sites, materials, and equipment to be made by competent persons designated by the employers.    An Employee working from an six and twelve pitch roof was exposed to falls of approximately 11 feet to a lower level. The employer did not initiate and maintain programs which provided for frequent and regular inspections of the job site, materials and equipment to be made by a competent person.

Issued

Jun 6, 2012

Abate by

Jun 7, 2012

Penalty

Initial $1,600 · Current $800 Reduced

General-duty citation text

29 CFR 1926.102(a)(1):     Employees shall be provided with eye and face protection equipment when machines or operations present potential eye or face injury from physical, chemical, or radiation agents.    An employee was using a pneumatic nail gun installing shingles without eye protection.

Issued

Jun 6, 2012

Abate by

Jun 7, 2012

Penalty

Initial $2,800 · Current $1,400 Reduced

General-duty citation text

29 CFR 1926.501(b)(13):     "Residential construction." Each employee engaged in residential construction activities 6 feet (1.8 m) or more above lower levels shall be protected by guardrail systems, safety net system, or personal fall arrest system unless another provision in paragraph (b) of this section provides for an alternative fall protection measure. Exception: When the employer can demonstrate that it is infeasible or creates a greater hazard to use these systems, the employer shall develop and implement a fall protection plan which meets the requirements of paragraph (k) of 1926.502.  Note: There is a presumption that it is feasible and will not create a greater hazard to implement at least one of the above-listed fall protection systems. Accordingly, the employer has the burden of establishing that it is appropriate to implement a fall protection plan which complies with 1926.502(k) for a particular workplace situation, in lieu of implementing any of those systems.      Employees working from an six and twelve pitch roof was exposed to falls of approximately 11 feet to a lower level. Employees were not protected against the hazard of falling.

Issued

Jun 6, 2012

Abate by

Jun 7, 2012

Penalty

Initial $2,800 · Current $1,400 Reduced

General-duty citation text

29 CFR 1926.1053(b)(1):     When portable ladders are used for access to an upper landing surface, the ladder side rails shall extend at least 3 feet (.9 m) above the upper landing surface to which the ladder is used to gain access; or, when such an extension is not possible because of the ladder's length, then the ladder shall be secured at its top to a rigid support that will not deflect, and a grasping device, such as a grabrail, shall be provided to assist employees in mounting and dismounting the ladder. In no case shall the extension be such that ladder deflection under a load would, by itself, cause the ladder to slip off its support.    An extension ladder to access work on the roof did not extend three feet above the upper landing surface nor were there any grasping device, such as a grab rail to assist employees in mounting and dismounting the ladder.