OSHA Inspection: ROBINSON ROOFING & SHEET METAL, INC.

Issued

2012-07-16 00:00:00

Abate by

2012-07-17 00:00:00

Penalty

Initial $2800.00 · Current $1200.00 Reduced

General-duty citation text

29 CFR 1926.501(b)(13):     "Residential construction." Each employee engaged in residential construction activities 6 feet (1.8 m) or more above lower levels shall be protected by guardrail systems, safety net system, or personal fall arrest system unless another provision in paragraph (b) of this section provides for an alternative fall protection measure. Exception: When the employer can demonstrate that it is infeasible or creates a greater hazard to use these systems, the employer shall develop and implement a fall protection plan which meets the requirements of paragraph (k) of 1926.502.  Note: There is a presumption that it is feasible and will not create a greater hazard to implement at least one of the above-listed fall protection systems. Accordingly, the employer has the burden of establishing that it is appropriate to implement a fall protection plan which complies with 1926.502(k) for a particular workplace situation, in lieu of implementing any of those systems.    Robinson Roofing & Sheet Metal, Inc. had an employee exposed to 10.5 ft. fall hazards without fall protection, on a residential construction site in Casey, Illinois.

Issued

2012-07-16 00:00:00

Abate by

2012-07-17 00:00:00

Penalty

Initial $2000.00 · Current $0.00 Reduced

General-duty citation text

29 CFR 1926.1053(b)(1):     When portable ladders are used for access to an upper landing surface, the ladder side rails shall extend at least 3 feet (.9 m) above the upper landing surface to which the ladder is used to gain access; or, when such an extension is not possible because of the ladder's length, then the ladder shall be secured at its top to a rigid support that will not deflect, and a grasping device, such as a grabrail, shall be provided to assist employees in mounting and dismounting the ladder. In no case shall the extension be such that ladder deflection under a load would, by itself, cause the ladder to slip off its support.    Robinson Roofing & Sheet Metal, Inc. had an employee exposed to 10.5 ft. fall hazards, while accessing and exiting the roof via an extension ladder that only extended 1 ft. above the upper landing surface of the roof, on a residential construction site in Casey, Illinois.