OSHA Inspection: CLS CONSTRUCTION*

Issued

Aug 2, 2012

Abate by

Aug 13, 2012

Penalty

Initial $2,000 · Current $1,500 Reduced

General-duty citation text

29 CFR 1926.1053(b)(1):     When portable ladders are used for access to an upper landing surface, the ladder side rails shall extend at least 3 feet (.9 m) above the upper landing surface to which the ladder is used to gain access; or, when such an extension is not possible because of the ladder's length, then the ladder shall be secured at its top to a rigid support that will not deflect, and a grasping device, such as a grabrail, shall be provided to assist employees in mounting and dismounting the ladder. In no case shall the extension be such that ladder deflection under a load would, by itself, cause the ladder to slip off its support.    The employer had employees exposed to fall hazards, while accessing and exiting the roof via one extension ladder that only extended 2.0 ft. above the upper landing surface of the roof, on a residential construction site in Sherman, Illinois.

Issued

Aug 2, 2012

Abate by

Aug 13, 2012

Penalty

Initial $0 · Current $0

General-duty citation text

29 CFR 1926.1060(a):     The employer shall provide a training program for each employee using ladders and stairways, as necessary. The program shall enable each employee to recognize hazards related to ladders and stairways, and shall train each employee in the procedures to be followed to minimize these hazards.    The employer had employees exposed to fall hazards, while accessing and exiting the roof via extension ladder that only extended 2.0 ft. above the upper landing surface of the roof, on a residential construction site in Sherman, Illinois.  The employer did not provide construction safety training to employees, in order to provide them with the knowledge necessary to recognize the hazards related to ladders, as well as the proper work procedures to follow, in order to minimize and eliminate these hazards.  This training would include:    a.	The nature of fall hazards in the work area,   b.	The correct procedures for erecting, maintaining, and disassembling the fall protection systems to be used,  c.	The proper construction use, placement, and care in handling of all ladders,  d.	The maximum intended load carrying capacities of ladders, and   e.	The standards contained in this subpart, Subpart X  Stairways and Ladders.

Issued

Aug 2, 2012

Abate by

Aug 13, 2012

Penalty

Initial $2,000 · Current $1,500 Reduced

General-duty citation text

29 CFR 1926.501(b)(13):     Employee(s) engaged in residential construction activities 6 feet (1.8 m) or more above lower levels were not protected by guardrail systems, safety net system, or personal fall arrest system, nor were employee(s) provided with an alternative fall protection measure under another provision of paragraph (b)    The employer had employees exposed to fall hazards without fall protection, on a residential construction site in Sherman, Illinois. These falls hazards were up to 16.5 ft height.

Issued

Aug 2, 2012

Abate by

Aug 13, 2012

Penalty

Initial $0 · Current $0

General-duty citation text

29 CFR 1926.503(a)(1):     The employer shall provide a training program for each employee who might be exposed to fall hazards. The program shall enable each employee to recognize the hazards of falling and shall train each employee in the procedures to be followed in order to minimize these hazards.    The employer had employees exposed to fall hazards without fall protection, on a residential construction site in Sherman, Illinois.    The employer did not provide construction safety training to employees, in order to provide them with the knowledge necessary to recognize the hazards of falling and the safety requirements associated with fall protection, as well as the proper work procedures to follow, in order to minimize and eliminate the fall hazards.

Issued

Aug 2, 2012

Abate by

Aug 13, 2012

Penalty

Initial $2,000 · Current $0 Reduced

General-duty citation text

29 CFR 1926.20(b)(1):     It shall be the responsibility of the employer to initiate and maintain such programs as may be necessary to comply with this part.    The employer had employees exposed to fall hazards and struck-by hazards in the eyes, on a residential construction site in Sherman, Illinois.  The employer did not have an effective safety and health program with specific work rules, competent person oversight, and employee training to govern employees activities.

Issued

Aug 2, 2012

Abate by

Aug 13, 2012

Penalty

Initial $0 · Current $0

General-duty citation text

29 CFR 1926.20(b)(2):     Such programs shall provide for frequent and regular inspections of the job sites, materials, and equipment to be made by competent persons designated by the employers.    The employer had employees exposed to fall hazards and struck-by hazards in the eyes, on a residential construction site in Sherman, Illinois.  The employer did not have a competent person at the construction site, who was competent in safety rules and requirements, in order to conduct frequent and periodic safety inspections at the construction site.