OSHA Inspection: BROOKS & SONS ROOFING LLC

Issued

Feb 19, 2013

Abate by

Mar 15, 2013

Penalty

Initial $2,000 · Current $1,000 Reduced

General-duty citation text

29 CFR 1926.20(b)(1):     It shall be the responsibility of the employer to initiate and maintain such programs as may be necessary to comply with this part.    Employees working from a 4 in 12 pitch roof were exposed to falls of approximately 10 feet 9 inches to a lower level. The employer did not initiate and maintain an accident prevention program to control and eliminate the hazards present at the jobsite in accordance with the OSHA regulations.

Issued

Feb 19, 2013

Abate by

Mar 15, 2013

Penalty

Initial $0 · Current $0

General-duty citation text

29 CFR 1926.20(b)(2):     Such programs shall provide for frequent and regular inspections of the job sites, materials, and equipment to be made by competent persons designated by the employers.    Employees working from a 4 in 12 pitch roof were exposed to falls of approximately 10 feet 9 inches to a lower level. The employer did not initiate and maintain programs which provided for frequent and regular inspections of the job site, materials and equipment to be made by a competent person.

Issued

Feb 19, 2013

Abate by

Feb 25, 2013

Penalty

Initial $1,600 · Current $875 Reduced

General-duty citation text

29 CFR 1926.102(a)(1):     Employees shall be provided with eye and face protection equipment when machines or operations present potential eye or face injury from physical, chemical, or radiation agents.    Employees installing shingles with a pneumatic nail gun were not wearing ANSI rated Z 87.1 eye protection. The employer failed to provide his employees with eye protection while using a pneumatic nail gun.

Issued

Feb 19, 2013

Abate by

Mar 18, 2013

Penalty

Initial $2,800 · Current $1,625 Reduced

General-duty citation text

29 CFR 1926.501(b)(13):     "Residential construction." Each employee engaged in residential construction activities 6 feet (1.8 m) or more above lower levels shall be protected by guardrail systems, safety net system, or personal fall arrest system unless another provision in paragraph (b) of this section provides for an alternative fall protection measure. Exception: When the employer can demonstrate that it is infeasible or creates a greater hazard to use these systems, the employer shall develop and implement a fall protection plan which meets the requirements of paragraph (k) of 1926.502.  Note: There is a presumption that it is feasible and will not create a greater hazard to implement at least one of the above-listed fall protection systems. Accordingly, the employer has the burden of establishing that it is appropriate to implement a fall protection plan which complies with 1926.502(k) for a particular workplace situation, in lieu of implementing any of those systems.    Employees working from a 4 in 12 pitch roof were exposed to falls of approximately 10 feet 9 inches to a lower level. Employees were not protected from falling by guardrail systems, safety net systems, or a personal fall arrest systems or any other approved means.