OSHA Inspection: KILAUEA BAKERY PAU HANA PIZZA LLC

Issued

2013-11-22 00:00:00

Abate by

2013-11-27 00:00:00

Penalty

Initial $2800.00 · Current $0.00 Reduced

General-duty citation text

29 CFR 1910.37(b)(2): Each exit was not clearly visible and marked by a sign reading "Exit":    FACILITY:  The rear exit was not marked by an Exit sign.

Issued

2013-11-22 00:00:00

Abate by

2013-11-27 00:00:00

Penalty

Initial $0.00 · Current $0.00

General-duty citation text

29 CFR 1910.37(b)(5): Each doorway or passage along an exit access that could be mistaken for an exit was not marked "Not an Exit" or similar designation, or be identified by a sign indicating its actual use (e.g. closet):    KITCHEN:  The doorway to the storage/walk ins area was not properly marked.

Issued

2013-11-22 00:00:00

Abate by

2013-12-02 00:00:00

Penalty

Initial $3500.00 · Current $1400.00 Reduced

General-duty citation text

29 CFR 1910.212(a)(1): One or more methods of machine guarding was not provided to protect the operator and other employees in the machine area from hazards such as those created by point of operation, ingoing nip points, rotating parts, flying chips and sparks:    KITCHEN:  The three Hobart vertical mixers, used by employees to mix, knead and whip food ingredients, were not guarded.

Issued

2013-11-22 00:00:00

Abate by

2013-12-02 00:00:00

Penalty

Initial $3500.00 · Current $1400.00 Reduced

General-duty citation text

29 CFR 1910.263(c)(3): Sprocket(s) and V-belt drive(s) of bakery machinery located within reach from platform(s) or passageway(s) or located within 8 feet 6 inches from the floor were not completely enclosed:    KITCHEN:  The sprockets on the dough sheeter, used by employees to make pizza crust, were not guarded

Issued

2013-11-22 00:00:00

Abate by

2013-12-02 00:00:00

Penalty

Initial $0.00 · Current $0.00

General-duty citation text

29 CFR 1910.263(g)(2): Handfed moulder(s) were not provided with either a belt-device or a hopper that extended high enough so that the hands of the operator could not get into the feed rolls:  KITCHEN:  The feed opening, at the top of the handfed moulder and used by employees to make pizza crust, was not guarded.

Issued

2013-11-22 00:00:00

Penalty

Initial $2380.00 · Current $952.00 Reduced

General-duty citation text

29 CFR 1910.303(b)(2): Listed or labeled electrical equipment was not used or installed in accordance with instructions included in the listing or labeling:    KITCHEN:  The Relocatable Power Taps (RPT) were not used according to theirs listing and labeling.

Issued

2013-11-22 00:00:00

Penalty

Initial $0.00 · Current $0.00

General-duty citation text

29 CFR 1910.305(g)(1)(iv)(A): Flexible cords and/or cables were used as a substitute for the fixed wiring of a structure  KITCHEN:  The Relocatable Power Taps (RPT) and associated extension cords were used as a substitute for fixed wiring.

Issued

2013-11-22 00:00:00

Penalty

Initial $2380.00 · Current $0.00 Reduced

General-duty citation text

29 CFR 1910.303(g)(1): Sufficient access and working space was not provided and maintained about all electric equipment (operating at 600 volts, nominal, or less to ground) to permit ready and safe operation and maintenance of such equipment:    EXTERIOR STORAGE AREA:  Access to the electrical panel was not maintained.

Issued

2013-11-22 00:00:00

Penalty

Initial $0.00 · Current $0.00

General-duty citation text

29 CFR 1910.304(f)(1)(iv): Overcurrent devices for circuits rated 600 volts, nominal, or less, were not readily accessible to each employee or authorized building management personnel:  EXTERIOR STORAGE AREA:  Access to the electrical circuit breaker panel was blocked by equipment stored in front of it.

Issued

2013-11-22 00:00:00

Penalty

Initial $0.00 · Current $0.00

General-duty citation text

29 CFR 1910.305(b)(1)(ii): Unused openings in boxes, cabinets, or fittings were not effectively closed:    EXTERIOR STORAGE AREA:  The unused openings in the electrical circuit breaker panel were not closed.

Issued

2013-11-22 00:00:00

Penalty

Initial $0.00 · Current $0.00

General-duty citation text

29 CFR 1910.305(b)(2)(i): Each outlet box in completed installations did not have a cover, faceplate, or fixture canopy:  EXTERIOR STORAGE AREA:  The faceplate cover on the duplex receptacle was broken and exposed employees to live electric parts.