OSHA Inspection: HARRISON BAKERY INC

Issued

May 6, 2015

Abate by

Jun 23, 2015

Penalty

Initial $1,600 · Current $960 Reduced

General-duty citation text

OSH ACT of 1970 Section (5)(a)(1): Section 5(a)(1) of the Occupational Safety and Health Act of 1970: The employer did not furnish employment and a place of employment which was free from recognized hazards that were causing or likely to cause death or serious physical harm to employees in that employees were exposed to struck by hazard.    a) Bread Shop, on or about 2/27/2015: Employee was using a Coffing 1 ton hoist to lift a hopper filled of dough without an inspection conducted on the hoist, employee was exposed to a struck by hazard.    b) Bread Shop, on or about 2/27/2015: Employee was using an under the hook lifting device without rated markings or inspection, employee was exposed to a struck by hazard.

Issued

May 6, 2015

Abate by

Jun 23, 2015

Penalty

Initial $1,200 · Current $720 Reduced

General-duty citation text

29 CFR 1910.23(a)(9): Each floor hole, into which persons could not accidentally walk, was not protected by a cover that leaves no openings more than 1 inch wide.    a) Maintenance Shop, on or about 2/27/2015: Employee was exposed to a trip hazard due to floor drainage pipe with broken cover plate.

Issued

May 6, 2015

Abate by

Jun 23, 2015

Penalty

Initial $1,200 · Current $0 Reduced

General-duty citation text

29 CFR 1910.37(b)(4): Signs were not posted along the exit access indicating the direction of travel to the nearest exit and exit discharge when the direction of travel to the exit or exit discharge was not immediately apparent:    a) Basement, on or about 2/27/2015: The designated fire exit sign could not be clearly seen and no signs indicating the direction of travel to the exit were posted.

Issued

May 6, 2015

Abate by

Jun 23, 2015

Penalty

Initial $1,200 · Current $720 Reduced

General-duty citation text

29 CFR 1910.151(c): Where employees were exposed to injurious corrosive materials, suitable facilities for quick drenching or flushing of the eyes and body were not provided within the work area for immediate emergency use:    a) Basement, on or about 2/27/2015: Employee adding water to fork truck battery was not provided with an eye wash station in the area, exposing employee to chemical burns.

Issued

May 6, 2015

Abate by

Jun 23, 2015

Penalty

Initial $2,000 · Current $1,200 Reduced

General-duty citation text

29 CFR 1910.303(b)(2): Listed or labeled electrical equipment was not used or installed in accordance with instructions included in the listing or labeling:    a) Basement, on or about 2/27/2015: Pipe heater was not installed per manufacturers instructions, exposing employees to a fire hazard.     b) Bread Shop, on or about 2/27/2015: Pipe heater was not installed per manufacturers instructions, exposing employees to a fire hazard.

Issued

May 6, 2015

Abate by

Jun 23, 2015

Penalty

Initial $0 · Current $0

General-duty citation text

29 CFR 1910.303(g)(1)(i)(A): For electric equipment operating at 600 volts, nominal, or less to ground, and likely to require examination, adjustment, servicing, or maintenance while energized, the depth of the working space in the direction of access to live parts (as measured from the live parts where they were exposed or from the enclosure front or opening where they were enclosed) was less than indicated in Table S-1 of Subpart S of Part 1910:  a) Basement, on or about 2/27/2015: Electrical panels and disconnect boxes were block by equipment and 55 gallon drums.   b) Bread Shop, on or about 2/27/2015: Electrical panels and disconnect boxes were block by bakery equipment.

Issued

May 6, 2015

Abate by

Jun 23, 2015

Penalty

Initial $0 · Current $0

General-duty citation text

29 CFR 1910.303(g)(2)(i): Except as elsewhere required or permitted by Subpart S of Part 1910, live parts of electric equipment operating  at 50 volts or more were not guarded against accidental contact by use of approved cabinets or other forms of approved enclosures or by any of the means identified in paragraphs (A), (B), (C), and (D) of 29 CFR 1910.303(g)(2)(i):  a) Basement, on or about 2/27/2015: Employee working near the control box with exposed live parts for refrigeration system was exposed to an electrical hazard.    b) Maintenance Shop, on or about 2/27/2015: Employee working near the control box with exposed live parts for refrigeration system was exposed to an electrical hazard.