OSHA Inspection: WARFEL CONSTRUCTION COMPANY, INC.

Issued

Oct 5, 2015

Penalty

Initial $2,800 · Current $2,300 Reduced

General-duty citation text

29 CFR 1926.501(b)(13): Each employee engaged in residential construction activities 6 feet or more above lower levels was not protected by a guardrail system, safety net system, or personal fall arrest system, or an alternative fall protection measure that meets a provision described in paragraph (b) of this section:       a) Lot #1 - The Retreat at Hazzard's Hill, Milford, DE - On or about June 25, 2015, the employer did not ensure employees used fall protection while working on the roof, approximately 30 feet above the grade, exposing employees to falls.      b) Lot #1 - The Retreat at Hazzard's Hill, Milford, DE - On or about June 25, 2015, the employer did not ensure employees used fall protection while working on the roof, approximately 15 feet above the grade, exposing employees to falls.     c) Lot #1 - The Retreat at Hazzard's Hill, Milford, DE - On or about June 25, 2015, the employer did not ensure employees used fall protection while working on the roof, approximately 12 feet above the grade, exposing employees to falls.

Issued

Oct 5, 2015

Abate by

Nov 23, 2015

Penalty

Initial $0 · Current $0

General-duty citation text

29 CFR 1926.503(a)(1): The employer did not train each employee who might be exposed to fall hazards to enable them to recognize fall hazards and the procedures to be followed in order to minimize these hazards:    a) Lot #1 - The Retreat at Hazzard's Hill, Milford, DE - On or about June 25, 2015, the employer failed to train each employee to recognize fall hazards and the procedures to minimize them, exposing employees to injuries.       ­Abatement Note     The training program must enable the employees to recognize the hazards of falling and must train each employee in the procedures to be followed in order to minimize these hazards.  Each employee must be trained by a competent person in the following:     1.  The nature of fall hazards in the work area;  2.  The correct procedures for erecting, maintaining, disassembling, and inspecting the fall protection systems to be used;  3.  The use and operation of guardrail systems, personal fall arrest systems, safety net systems, warning line systems, safety        monitoring systems, controlled access zones, and other protection to be used;  4.  The role of each employee in the safety monitoring system when this system is used;  5.  The limitations on the use of mechanical equipment during the performance of roofing work on low-sloped roofs;  6.  The correct procedures for the handling and storage of equipment and materials and the erection of overhead protection;  7.  The role of employees in fall protection plans;  8.  The standards contained in this subpart.     The employer must verify compliance with paragraph (a) of this section by preparing a written certification record that will contain the name or other identity of the employee trained, the date(s) of the training, and the signature of the person who conducted the training or the signature of the employer.

Issued

Oct 5, 2015

Penalty

Initial $1,600 · Current $1,300 Reduced

General-duty citation text

29 CFR 1926.1053(b)(1): When portable ladders were used for access to an upper landing surface, the ladder side rails did not extend at least 3 feet above the upper landing surface to which the ladder was used to gain access.               a) Lot #1 - The Retreat at Hazzard's Hill, Milford, DE - On or about June 25, 2015, the employer did not ensure employees used extension ladders that extended at least 3 feet above the upper landing to access the roof, exposing employees to falls.

Issued

Oct 5, 2015

Abate by

Nov 23, 2015

Penalty

Initial $0 · Current $0

General-duty citation text

29 CFR 1926.1060(a): The employer did not provide a training program for each employee using ladders and stairways, as necessary, which would train each employee in the procedures to be followed to minimize hazards related to ladders and stairways:    a) Lot #1 - The Retreat at Hazzard's Hill, Milford, DE - On or about June 25, 2015, the employer failed to provide a training program for employees to minimize hazards related to using ladders and stairways, exposing employees to falls.

Issued

Oct 5, 2015

Abate by

Nov 23, 2015

Penalty

Initial $0 · Current $0

General-duty citation text

29 CFR 1926.602(d): Powered industrial truck operator training.  Note: The requirements applicable to construction work under this paragraph are identical to those set forth at 1910.178(l) of this chapter: (A) Each powered industrial truck operator did not complete training as required:   a) Lot #1 - The Retreat at Hazzard's Hill, Milford, DE - On or about June 25, 2015, the employer did not ensure each industrial truck operator was trained.