OSHA Inspection: CLAUDIO CONSTRUCTION, INC.

Issued

Oct 9, 2015

Penalty

Initial $1,600 · Current $0 Reduced

General-duty citation text

29 CFR 1926.451(c)(2):   Supported scaffold poles, legs, posts, frames, and uprights did not bear on base plates and mud sills or other adequate firm foundation:  a)  1611 Springfield Avenue, Maplewood, NJ.  Employees were exposed to injury through a scaffold collapse as concrete blocks, which are not an adequate foundation, were used to support the scaffold on its West side.   Violation observed on or about 08/06/2015.

Issued

Oct 9, 2015

Penalty

Initial $2,800 · Current $0 Reduced

General-duty citation text

29 CFR 1926.451(f)(6):   Scaffolds were erected, used, dismantled, altered, or moved such that they, or any conductive material handled on them, could have come closer than the minimum distances established for specific voltages as set forth in the table in subparagraph (f)(6):  a)  1611 Springfield Avenue, Maplewood, NJ.  Employees were exposed to electrocution as they had erected and worked on the fabricated-frame scaffolding within 3 to 4 feet from the 13 kV power line.  Violation observed on or about 08/06/2015.

Issued

Oct 9, 2015

Penalty

Initial $1,600 · Current $0 Reduced

General-duty citation text

29 CFR 1926.451(f)(7):   Scaffolds were not erected, moved, dismantled, or altered, by trained and experienced employees under the supervision and direction of a competent person qualified in scaffold erection, moving, dismantling or alteration; such activities were not performed only by experienced and trained employees selected for such work by the competent person.   a)  1611 Springfield Avenue, Maplewood, NJ.  Employees were exposed to the hazards of falls and electrocution given that this fabricated frame scaffold was not erected or dismantled by a trained and experienced employees under the supervision and direction of a competent person.     Violation observed on or about 08/06/2015.

Issued

Oct 9, 2015

Penalty

Initial $2,800 · Current $0 Reduced

General-duty citation text

29 CFR 1926.451(g)(1)(vii):   Each employee on a scaffold, not otherwise specified in paragraphs (g)(1)(i) through (g)(1)(vi) of this section, more than 10 feet (3.1 m) above lower level was not protected from falls by the use of personal fall arrest systems or guardrail systems meeting the requirements of paragraph (g)(4) of this section:  a)  1611 Springfield Avenue, Maplewood, NJ.  Employees were exposed to falls of up to 12 1/2 to 18 1/2 feet to the sidewalk canopy or to the ground below as guardrails were missing and personal fall arrest systems were not in use.    Violation observed on or about 08/06/2015.

Issued

Oct 9, 2015

Penalty

Initial $2,000 · Current $0 Reduced

General-duty citation text

29 CFR 1926.502(b)(1):   The top edge height of the top rails, or equivalent guardrail system members, was not 42 inches (1.1 m) plus or minus 3 inches (8 cm) above the walking/working level:  a)  1611 Springfield Avenue, at the Top Stairway Landing at the Rear Entrance to the Building, Maplewood, NJ.  Employees were exposed to falls of 10 to 11 feet to the floor below as the top edge height of the guardrail was only 37 inches which allows for an "over-the-railing" fall.  Violation observed on or about 08/06/2015.

Issued

Oct 9, 2015

Penalty

Initial $1,600 · Current $0 Reduced

General-duty citation text

29 CFR 1926.701(b):   All protruding reinforcing steel, onto and/or into which employees could fall or come against, was not guarded to eliminate the hazard of impalement:  a)  1611 Springfield Avenue, at the Ground Floor Landing in front of the Elevator, Maplewood, NJ.  Employees were exposed to impalement injury from unprotected rebar ends.  Violation observed on or about 08/06/2015.

Issued

Oct 9, 2015

Penalty

Initial $2,400 · Current $0 Reduced

General-duty citation text

29 CFR 1926.1052(b)(3):   Treads for temporary stairway service were not installed the full width and depth of the stair:  a)  1611 Springfield Avenue, Maplewood, NJ.  Employees were exposed to falls down a flight of stairs given that the top treads of the temporary wood stairs were not installed the full width of the stairs with up to 2 inch wide gaps between wood treads.  Violation observed on or about 08/06/2015.

Issued

Oct 9, 2015

Penalty

Initial $1,600 · Current $0 Reduced

General-duty citation text

29 CFR 1926.1052(c)(4): Midrails, screens, mesh, intermediate vertical members, or equivalent intermediate structural members were not provided between the top rail of the stairrail system and the stairway steps:  a)  1611 Springfield Avenue, On the Rear Stairway, Maplewood, NJ.  Employees were exposed to falls down to the next flight of stairs given that there were no midrails along the entire stairway.    Violation observed on or about 08/06/2015.