OSHA Inspection: ELADIO'S CONSTRUCTION CORPORATION

Issued

Jun 17, 2016

Abate by

Jun 23, 2016

Penalty

Initial $1,200 · Current $0 Reduced

Hazardous substances 0520S103

General-duty citation text

29 CFR 1926.28(a): The employer did not require the wearing of appropriate personal protective equipment in all operations where there is an exposure to hazardous conditions.  a. 1333 South 23rd Street, Philadelphia, PA 19146-4244 - The employer did not provide the use of protective gloves where employees were handling Lehigh Masonry Cement, Type N, cement for application to the exterior walls of a residential building.  This chemical can cause skin burns and skin irritation. Observed On or About March 1, 2016

Issued

Jun 17, 2016

Abate by

Jun 24, 2016

Penalty

Initial $1,600 · Current $0 Reduced

General-duty citation text

29 CFR 1926.100(a): Employees working in areas where there was a possible danger of head injury from impact, or falling or flying objects, or from electrical shock and burns, were not protected by protective helmets:  a. 1333 South 23rd Street, Philadelphia, PA 19146-4244  The employer did not provide and require employees to wear protective hard hats for protection from falling objects while performing masonry work under the second level of a fabricated frame scaffold.    Observed On or About March 1, 2016

Issued

Jun 17, 2016

Abate by

Jun 24, 2016

Penalty

Initial $1,600 · Current $0 Reduced

Hazardous substances 05201610S103

General-duty citation text

29 CFR 1926.102(a)(1): Eye and face protective equipment were not used when machines or operations presented potential eye or face injury from physical, chemical, or radiation agents:   a. 1333 South 23rd Street, Philadelphia, PA 19146-4244 - The employer did not provide eye and face protection (e.g. face shields) when employees were handling Lehigh Masonry Cement (Type N), which can cause skin and eye burns/irritation.  Observed On or About March 1, 2016

Issued

Jun 17, 2016

Abate by

Jun 24, 2016

Penalty

Initial $2,800 · Current $0 Reduced

General-duty citation text

29 CFR 1926.451(b)(1)(i): Each platform unit (e.g., scaffold plank, fabricated plank, fabricated deck, or fabricated platform) was not installed so that the space between adjacent units and the space between the platform and the uprights were no more than 1 inch (2.5 cm) wide, except where the employer can demonstrate that a wider space is necessary:  a.  1333 South 23rd Street, Philadelphia, PA 19146-4244 - The employer did not provide a fully planked or decked second tier platform of a tubular steel supported scaffold.  Four employees were performing masonry operations on the second tier of the scaffold that was approximately 12 feet above a sidewalk.  Observed On or About March 1, 2016

Issued

Jun 17, 2016

Abate by

Jun 23, 2016

Penalty

Initial $0 · Current $0

General-duty citation text

29 CFR 1926.451(e)(1): When scaffold platforms were more than 2 feet (0.6 m) above or below a point of access, portable ladders, hook-on ladders, attachable ladders, stair towers (scaffold stairways/towers), stairway-type ladders (such as ladder stands), ramps, walkways, integral prefabricated scaffold access, or direct access from other scaffold, sturcure, personnel hoist, or similar surface was not used.  Crossbraces were used as a means of access:   a. 1333 South 23rd Street, Philadelphia, PA 19146-4244 - The employer did not provide a means to ascend and descend from one level to another level of the scaffold by the use of ladders and stair towers.  Employees accessed the second tier level of the scaffold, that was approximately 12 feet above the sidewalk, by climbing the scaffold up-rights.  Observed On or About March 1, 2016

Issued

Jun 17, 2016

Abate by

Jun 23, 2016

Penalty

Initial $2,800 · Current $0 Reduced

General-duty citation text

29 CFR 1926.451(g)(4)(i): Guardrail systems were not installed along all open sides and ends of platforms before being released for use by employees other than erection/dismantling crews:  a.  1333 South 23rd Street, Philadelphia, PA 19146-4244 - The employer did not ensure that employees who were performing masonry work on the second tier of a scaffold, that was approximately 12 feet above a sidewalk, were protected by a guardrail system. Observed On or About March 1, 2016

Issued

Jun 17, 2016

Abate by

Jun 23, 2016

Penalty

Initial $2,400 · Current $0 Reduced

General-duty citation text

29 CFR 1926.451(h)(1): Each employee on a scaffold was not provided with additional protection from falling hand tools, debris, and other small objects through the installation of toeboards, screens, guardrail systems, or through the erection of debris nets, catch platforms, or canopy structures that contain or deflect the falling objects.  For falling objects too large, heavy or massive to be contained or deflected, the employer did not place and secure such potential falling objects away from the edge of the surface from which they could fall.   a. 1333 South 23rd Street, Philadelphia, PA 19146-4244 - The employer did not install protection such as toe boards along the edges of the second tier of a scaffold to protect employees from falling materials used for conducting masonry work.  Four employees were performing masonry work on the second level of a fabricated frame scaffold while two other employees were working on the ground.  Observed On or About March 1, 2016

Issued

Jun 17, 2016

Abate by

Jun 23, 2016

Penalty

Initial $1,600 · Current $0 Reduced

Hazardous substances 05201610S103

General-duty citation text

29 CFR 1910.1200(e)(1): The employer did not develop, implement, and/or maintain at the workplace a written hazard communication program which describes how the criteria specified in 29 CFR 1910.1200(f), (g), and (h) will be met:   a. 1333 South 23rd Street, Philadelphia, PA 19146-4244 - The employer did not develop and implement a written Hazard Communication Program for employees who were exposed to chemicals such as, but not limited to quartz, limestone, etc. contained in Lehigh Masonry Cement, Type N for application to the exterior walls of a residential building. Observed On or About March 1, 2016

Issued

Jun 17, 2016

Abate by

Jun 23, 2016

Penalty

Initial $0 · Current $0

Hazardous substances 0505S103

General-duty citation text

29 CFR 1910.1200(g)(1): The employer did not have a material safety data sheet for each hazardous chemical in use:   a. 1333 South 23rd Street, Philadelphia, PA 19146-4244  - The employer did not provide safety data sheet (sds) for Lehigh Masonry Cement, Type N, containing chemicals such as, but not limited to quartz, limestone, etc., which employees applied to the exterior walls of a residential building. Observed On or About March 1, 2016

Issued

Jun 17, 2016

Abate by

Jul 7, 2016

Penalty

Initial $0 · Current $0

Hazardous substances 0505S103

General-duty citation text

29 CFR 1910.1200(h)(1): Employees were not provided effective information and training on hazardous chemicals in their work area at the time of their initial assignment and whenever a new hazard that the employees had not been previously trained about was introduced into their work area: (Construction Reference: 1926.59)  a. 1333 South 23rd Street, Philadelphia, PA 19146-4244 - The employer did not provide employees with information and training on the hazardous chemicals in their work area, such as Lehigh Masonry Cement, Type N, which contains chemicals such as, quartz, limestone, etc.  Observed On or About March 1, 2016