OSHA Inspection: NIKLYN CORP

Issued

2017-07-28 00:00:00

Abate by

2017-12-12 00:00:00

Penalty

Initial $2716.00 · Current $1358.00 Reduced

General-duty citation text

29 CFR 1910.106(e)(2)(ii)(a): Except as provided in subdivisions (b) and (c) of this subdivision, all storage shall comply with paragraph (d) (3) or (4) of this section.    Back room:  The large stockpile of flammable liquids were stored outside of an inside storage room or storage cabinet.

Issued

2017-07-28 00:00:00

Abate by

2017-12-12 00:00:00

Penalty

Initial $0.00 · Current $0.00

General-duty citation text

29 CFR 1910.107(e)(2): The quantity of flammable liquids or liquids with a flashpoint greater than 199.4 degrees F (93 degrees C) kept in the vicinity of spraying operations were not a minimum required for operations or they exceeded a supply for one day or one shift:   Backroom: The quantity of the flammable liquids stored within very close proximity of the spraying operation were a lot more than for the quantity that needed for one day or one shift operation.

Issued

2017-07-28 00:00:00

Abate by

2017-08-03 00:00:00

Penalty

Initial $3803.00 · Current $1902.00 Reduced

General-duty citation text

29 CFR 1910.107(l)(3): The applicable provisions of the Standard for Ovens and Furnaces, NFPA No. 86A-1969, were not met:    Shop: The industrial oven did not meet the requirements of  NFPA No. 86A-1969, creating potential employee exposure to explosion and/or fire hazards.

Issued

2017-07-28 00:00:00

Abate by

2017-08-23 00:00:00

Penalty

Initial $2173.00 · Current $1087.00 Reduced

General-duty citation text

29 CFR 1910.132(d)(1): The employer did not assess the workplace to determine if hazards are present, or are likely to be present, which necessitate the use of personal protective equipment (PPE):    Workplace: The employer did not assess the workplace to determine which necessitate and appropriate types of personal protective equipment (PPE) for employees.

Issued

2017-07-28 00:00:00

Abate by

2017-08-23 00:00:00

Penalty

Initial $0.00 · Current $0.00

General-duty citation text

29 CFR 1910.132(f)(1): The employer shall provide training to each employee who is required by this section to use PPE:of personal protective equipment (PPE):  Workplace: The employer did not provide training and information to the employees on the Workplace Hazard Assessment for PPE.

Issued

2017-07-28 00:00:00

Abate by

2017-08-09 00:00:00

Penalty

Initial $2716.00 · Current $1358.00 Reduced

General-duty citation text

29 CFR 1910.219(b)(1): Flywheel(s) with parts seven feet or less above floor(s) or platform(s) were not guarded in accordance with the requirements specified in 29 CFR 1910.219(b)(1)(i) through (b)(1)(iv)(a)    Shop; The flywheel located on the blower motor of the Wisconsin industrial oven was not guarded exposing employees to ingoing nip points.

Issued

2017-07-28 00:00:00

Abate by

2017-08-09 00:00:00

Penalty

Initial $3803.00 · Current $1902.00 Reduced

General-duty citation text

29 CFR 1910.303(b)(2): Listed or labeled electrical equipment was not used or installed in accordance with instructions included in the listing or labeling:    Shop:  The circuit breaker panel was not appropriately installed with proper means of securing and proper cove.

Issued

2017-07-28 00:00:00

Penalty

Initial $0.00 · Current $0.00

General-duty citation text

29 CFR 1910.303(g)(2)(i): Except as elsewhere required or permitted by Subpart S of Part 1910, live parts of electric equipment operating  at 50 volts or more were not guarded against accidental contact by use of approved cabinets or other forms of approved enclosures or by any of the means identified in paragraphs (A), (B), (C), and (D) of 29 CFR 1910.303(g)(2)(i):  Shop:  The electrical boxes, such as (but not limited to) panels, junctions boxes and breaker boxes were not appropriately covered, exposing live parts ranging from 277/ 480 volts to 110/ 220 volts.

Issued

2017-07-28 00:00:00

Penalty

Initial $1630.00 · Current $815.00 Reduced

General-duty citation text

29 CFR 1910.1200(e)(1): Employer had not developed or implemented a written hazard communication program included the requirements outlined in 29 CFR 1910.1200(e)(1)(i) and (e)(1)(ii):     Workplace: The employer did not develop, implement, and maintain at each workplace, a written hazard communication program where employees were required to work with chemicals.

Issued

2017-07-28 00:00:00

Abate by

2017-08-16 00:00:00

Penalty

Initial $0.00 · Current $0.00

General-duty citation text

29 CFR 1910.1200(e)(1)(i): The employer did not compile a list of the hazardous chemicals known to be present using a product identifier that was referenced on the appropriate safety data sheet.  Workplace:  The employer did not develop a list of hazardous chemical that were present in the workplace.