OSHA Inspection: ELTON NASCIMENTO DASILVA

Issued

May 9, 2022

Penalty

Initial $2,486 · Current $2,486

General-duty citation text

29 CFR  1926.25(a):During the course of construction, alteration, or repairs, form and scrap lumber with protruding nails, and all other debris, shall be kept cleared from work areas, passageways, and stairs, in and around buildings or other structures.  A) 17 W Main St Bound Brook, NJ 08805  Employees were exposed to slip, trip and fall hazards from the lack of housekeeping. Framing materials such as wood, wooden framing members with nails protruding through, and miscellaneous tool & equipment were left scattered about on the lower roof passageway.   Hazard noted on or about 11/10/21

Issued

May 9, 2022

Penalty

Initial $4,351 · Current $4,351

General-duty citation text

29 CFR  1926.501(b)(1):"Unprotected sides and edges." Each employee on a walking/working surface (horizontal and vertical surface) with an unprotected side or edge which is 6 feet (1.8 m) or more above a lower level shall be protected from falling by the use of guardrail systems, safety net systems, or personal fall arrest systems.  A) 17 W Main St Bound Brook, NJ 08805  Employees were exposed to fall hazards of up to 13ft while using the lower roof to access the worksite without utilizing any form of fall protection.   As employees exited the ladder that led to the lower roof they were exposed to an unprotected edge with a fall height of 13ft.  Hazard noted on 11/10/22

Issued

May 9, 2022

Penalty

Initial $2,486 · Current $2,486

General-duty citation text

29 CFR  1926.501(b)(4)(ii):Each employee on a walking/working surface shall be protected from tripping in or stepping into or through holes (including skylights) by covers.  A) 17 W Main St Bound Brook, NJ 08805  Holes approximately 6 inches by 6 inches were cut into the plywood floor to allow for water drainage from rain. The holes were left uncovered and created a slip, trip and fall hazard.   Hazard noted on or about 11/10/21

Issued

May 9, 2022

Penalty

Initial $4,351 · Current $4,351

General-duty citation text

29 CFR  1926.501(b)(14):"Wall openings." Each employee working on, at, above, or near wall openings (including those with chutes attached) where the outside bottom edge of the wall opening is 6 feet (1.8 m) or more above lower levels and the inside bottom edge of the wall opening is less than 39 inches (1.0 m) above the walking/working surface, shall be protected from falling by the use of a guardrail system, a safety net system, or a personal fall arrest system.  A)17 W Main St Bound Brook, NJ 08805 4th floor  Employees were exposed to fall hazard throughout the jobsite due to unguarded window openings on the 2nd and 3rd floors of the jobsite.   Hazard noted on or about 11/10/21

Issued

May 9, 2022

Penalty

Initial $2,486 · Current $2,486

General-duty citation text

29 CFR  1926.1051(a):A stairway or ladder shall be provided at all personnel points of access where there is a break in elevation of 19 inches (48 cm) or more, and no ramp, runway, sloped embankment, or personnel hoist is provided.  A)17 W Main St Bound Brook, NJ 08805  Employees were not provided with a stairway or ladder to enter up and over a 3ft height window opening being used to access the jobsite.   Hazard noted on or about 11/10/21

Issued

May 9, 2022

Penalty

Initial $4,351 · Current $4,351

General-duty citation text

29 CFR  1926.1053(b)(4):Ladders shall be used only for the purpose for which they were designed.  A)17 W Main St Bound Brook, NJ 08805  An A-frame stepladder was being used in the closed position and the edge of the building to access a upper landing on the lower roof. A ladder of this type is not to be used as a straight ladder, ladder should be stood up with the spreaders locked.   Hazard noted on or about 11/10/21

Issued

May 9, 2022

Penalty

Initial $14,502 · Current $14,502

General-duty citation text

29 CFR  1926.1417(w):A tag or restraint line must be used if necessary to prevent rotation of the load that would be hazardous.  A)17 W Main St Bound Brook, NJ 08805  Employees were flying in floor trusses approximately 24ft in length from the ground level up to the 4th floor without the use of taglines to prevent the load from spinning.  Hazard noted on or about 11/10/21

Issued

May 9, 2022

Penalty

Initial $4,351 · Current $4,351

General-duty citation text

29 CFR  1926.1425(c)(3):The materials must be rigged by a qualified rigger.  A)17 W Main St Bound Brook, NJ 08805  The rigger that was securing the floor trusses that were approximately 24ft in length to the crane to be lifted into place was not qualified as per the OSHA standards.    Hazard noted on or about 11/10/21

Issued

May 9, 2022

Penalty

Initial $14,502 · Current $14,502

General-duty citation text

29 CFR  1926.1425(e)(2):The employer failed to ensure that only employees essential to the material lifting operation were permitted in the fall zone (but not directly under the load).   A)17 W Main St Bound Brook, NJ 08805  When the floor trusses were being lifted into place the area below the load was not kept clear of employees who were not deemed essential to the material lifting operation. Employees  were in close proximity to the suspended floor trusses.    Hazard noted on or about 11/10/21

Issued

May 9, 2022

Penalty

Initial $14,502 · Current $14,502

General-duty citation text

29 CFR  1926.1428(a):The employer of the signal person must ensure that each signal person meets the Qualification Requirements (paragraph (c) of this section) prior to giving any signals. This requirement must be met by using either Option (1) or Option (2) of this section.  A)17 W Main St Bound Brook, NJ 08805  The signalman used to signal the crane operator who was flying in the floor trusses that were approximately 24ft in length was not qualified as per the OSHA standards.     Hazard noted on or about 11/10/21