OSHA Inspection: JOSE JUAN OSORIO MORALES LLC

Issued

May 3, 2022

Abate by

Jun 13, 2022

Penalty

Initial $3,419 · Current $1,880 Reduced

General-duty citation text

29 CFR  1926.20(b)(1):It shall be the responsibility of the employer to initiate and maintain such programs as may be necessary to comply with this part.  a. Located at 20 Erin Hills Road in Commercial Point, Ohio: On or about April 22, 2022, the employer did not maintain an effective safety and health program onsite to ensure that fall and struck-by hazards were identified and corrected while employees performed roofing work.

Issued

May 3, 2022

Abate by

Jun 13, 2022

Penalty

Initial $3,419 · Current $1,880 Reduced

General-duty citation text

29 CFR  1926.102(a)(1):The employer shall ensure that each affected employee uses appropriate eye or face protection when exposed to eye or face hazards from flying particles, molten metal, liquid chemicals, acids or caustic liquids, chemical gases or vapors, or potentially injurious light radiation.  a. Located at 20 Erin Hills Road in Commercial Point, Ohio: On or about April 22, 2022, employees were operating pneumatic nailers to fasten shingles to the roof without eye protection, thereby exposing employees to struck-by hazards.

Issued

May 3, 2022

Abate by

Jun 13, 2022

Penalty

Initial $3,419 · Current $1,880 Reduced

General-duty citation text

29 CFR  1926.502(d)(15):Anchorages used for attachment of personal fall arrest equipment shall be independent of any anchorage being used to support or suspend platforms and capable of supporting at least 5,000 pounds (22.2 kN) per employee attached.  a. Located at 20 Erin Hills Road in Commercial Point, Ohio: On or about April 22, 2022, employees were performing roofing work with a full body fall arrest harness attached to rope lifelines that were wrapped around the ridge and nail plate of the roof trusses. The personal fall arrest systems in use did not have adequate anchorage, thereby exposing employees to a fall hazard.

Issued

May 3, 2022

Abate by

Jun 13, 2022

Penalty

Initial $6,838 · Current $1,880 Reduced

General-duty citation text

29 CFR  1926.501(b)(13):"Residential construction." Each employee engaged in residential construction activities 6 feet (1.8 m) or more above lower levels shall be protected by guardrail systems, safety net system, or personal fall arrest system unless another provision in paragraph (b) of this section provides for an alternative fall protection measure.   a. Located at 20 Erin Hills Road in Commercial Point, Ohio: On or about April 22, 2022, employees were performing roofing work while unhooked from a lifeline, thereby exposing employees to a fall hazard from approximately twelve feet.   Jose Juan Osorio Morales was previously cited for a serious violation of this Occupational Safety and Health standard 29 CFR 1926.501(b)(13), which was contained in OSHA inspection number 1390338, citation number 1, item number 1a and was affirmed as a final order on 05/03/2019, with respect to a workplace located at 618 Ludham Trail, Lot 178, Pickerington, Ohio 43147.

Issued

May 3, 2022

Abate by

Jun 13, 2022

Penalty

Initial $0 · Current $0

General-duty citation text

29 CFR 1926.502(d)(16)(iii): Personal fall arrest systems, when stopping a fall, shall: be rigged such that an employee can neither free fall more than 6 feet (1.8 m), nor contact any lower level.  a. Located at 20 Erin Hills Road in Commercial Point, Ohio: On or about April 22, 2022, an employee was performing roofing work with a full body fall arrest harness attached to a rope lifeline that was not rigged to prevent a fall from a height less than six feet.   Jose Juan Osorio Morales was previously cited for a serious violation of this Occupational Safety and Health standard 29 CFR 1926.502(d)(16)(iii), which was contained in OSHA inspection number 1390338, citation number 1, item number 1b and was affirmed as a final order on 05/03/2019, with respect to a workplace located at 618 Ludham Trail, Lot 178, Pickerington, Ohio 43147.