OSHA Inspection: AREA 920 ROOFING LLC

Issued

Sep 30, 2022

Penalty

Initial $4,351 · Current $2,176 Reduced

General-duty citation text

29 CFR  1926.501(b)(13): "Residential construction." Each employee engaged in residential construction activities 6 feet (1.8 m) or more above lower levels shall be protected by guardrail systems, safety net system, or personal fall arrest system unless another provision in paragraph (b) of this section provides for an alternative fall protection measure. Exception: When the employer can demonstrate that it is infeasible or creates a greater hazard to use these systems, the employer shall develop and implement a fall protection plan which meets the requirements of paragraph (k) of 1926.502. Note: There is a presumption that it is feasible and will not create a greater hazard to implement at least one of the above-listed fall protection systems. Accordingly, the employer has the burden of establishing that it is appropriate to implement a fall protection plan which complies with 1926.502(k) for a particular workplace situation, in lieu of implementing any of those systems.  On or about September 21, 2022, at an establishment located at 5032 Silentwind Way in Appleton, Wisconsin, employees of Area 920 Roofing LLC were performing residential roofing activities with no form of conventional fall protection while exposed to falls of over 10 feet.

Issued

Sep 30, 2022

Abate by

Nov 7, 2022

Penalty

Initial $0 · Current $0

General-duty citation text

29 CFR  1926.503(a)(1): The employer shall provide a training program for each employee who might be exposed to fall hazards. The program shall enable each employee to recognize the hazards of falling and shall train each employee in the procedures to be followed in order to minimize these hazards.  On or about September 21, 2022, at an establishment located at 5032 Silentwind Way in Appleton, Wisconsin, employees of Area 920 Roofing LLC were performing residential roofing activities having not received training on the hazards associated with falls while exposed to falls of over 10 feet.

Issued

Sep 30, 2022

Abate by

Nov 7, 2022

Penalty

Initial $4,351 · Current $2,176 Reduced

General-duty citation text

29 CFR  1926.1053(b)(1): When portable ladders are used for access to an upper landing surface, the ladder side rails shall extend at least 3 feet (.9 m) above the upper landing surface to which the ladder is used to gain access; or, when such an extension is not possible because of the ladder's length, then the ladder shall be secured at its top to a rigid support that will not deflect, and a grasping device, such as a grabrail, shall be provided to assist employees in mounting and dismounting the ladder. In no case shall the extension be such that ladder deflection under a load would, by itself, cause the ladder to slip off its support.  On or about September 21, 2022, at an establishment located at 5032 Silentwind Way in Appleton, Wisconsin, employees of Area 920 Roofing LLC were utilizing a ladder that had not been extended 3 feet above the upper landing surface while exposed to falls of over 10 feet.

Issued

Sep 30, 2022

Abate by

Nov 7, 2022

Penalty

Initial $0 · Current $0

General-duty citation text

29 CFR  1926.1053(b)(9): The area around the top and bottom of ladders shall be kept clear.  On or about September 21, 2022, at an establishment located at 5032 Silentwind Way in Appleton, Wisconsin, employees of Area 920 Roofing LLC were utilizing an extension ladder that did not have a clear area around the bottom while being exposed to trip and fall hazards.

Issued

Sep 30, 2022

Abate by

Nov 7, 2022

Penalty

Initial $0 · Current $0

General-duty citation text

29 CFR  1926.1060(a): The employer shall provide a training program for each employee using ladders and stairways, as necessary. The program shall enable each employee to recognize hazards related to ladders and stairways, and shall train each employee in the procedures to be followed to minimize these hazards.  On or about September 21, 2022, at an establishment located at 5032 Silentwind Way in Appleton, Wisconsin, employees of Area 920 Roofing LLC were utilizing ladders and had not been trained on the hazards associated with ladders while exposed to falls of over 10 feet.