OSHA Inspection: JOSE LUIS ZARUMA DBA Z 1 CONSTRUCTION LLC

Issued

Feb 23, 2024

Abate by

Mar 15, 2024

Penalty

Initial $2,765 · Current $2,765

General-duty citation text

29 CFR 1926.503(b)(1): The employer shall verify compliance with paragraph (a) of this section by preparing a written certification record. The written certification record shall contain the name or other identity of the employee trained, the date(s) of the training, and the signature of the person who conducted the training or the signature of the employer. If the employer relies on training conducted by another employer or completed prior to the effective date of this section, the certification record shall indicate the date the employer determined the prior training was adequate rather than the date of actual training.     On or about December 7, 2023, the employer did not certify that employees had been trained to recognize and minimize fall hazards. Employees were exposed to fall hazards in excess of 10 feet while performing roof installation activities without using fall protection.    Abatement documentation is required for this item in accordance with 29 CFR 1903.19(d).

Issued

Feb 23, 2024

Penalty

Initial $2,074 · Current $2,074

General-duty citation text

29 CFR 1926.1053(b)(1): When portable ladders are used for access to an upper landing surface, the ladder side rails shall extend at least 3 feet (.9 m) above the upper landing surface to which the ladder is used to gain access; or, when such an extension is not possible because of the ladder's length, then the ladder shall be secured at its top to a rigid support that will not deflect, and a grasping device, such as a grab rail, shall be provided to assist employees in mounting and dismounting the ladder. In no case shall the extension be such that ladder deflection under a load would, by itself, cause the ladder to slip off its support.    On or about December 7, 2023, the portable ladder used to access the roof level did not extend at least three (3') feet above the upper landing surface, thereby exposing employees to fall hazards in excess of 10 feet. .     No abatement certification or documentation is required for this item.

Issued

Feb 23, 2024

Penalty

Initial $5,531 · Current $5,531

General-duty citation text

29 CFR 1926.102(a)(1): The employer shall ensure that each affected employee uses appropriate eye or face protection when exposed to eye or face hazards from flying particles, molten metal, liquid chemicals, acids or caustic liquids, chemical gases or vapors, or potentially injurious light radiation.    On or about December 7, 2023, employees engaged in residential roofing operations were exposed to eye injury hazards while operating pneumatic nail guns without eye protection. Employer did not ensure that employees that were engaged in roofing installations activities utilizing pneumatic guns were utilizing safety glasses.    No abatement certification or documentation is required for this item.   Jose Luis Zaruma dba Z 1 Construction LLC was previously cited for a violation of this occupational safety and health standard or its equivalent standard 29 CFR 1926.102(a)(1), which was contained in OSHA inspection number 1524874, citation number 1, item number 1 and was affirmed as a final order on June 9, 2021, with respect to a workplace located at 621-633 LeParc Ct., Buffalo Grove, IL 60089.

Issued

Feb 23, 2024

Penalty

Initial $9,679 · Current $9,679

General-duty citation text

29 CFR 1926.501(b)(13): "Residential construction." Each employee engaged in residential construction activities 6 feet (1.8 m) or more above lower levels shall be protected by guardrail systems, safety net system, or personal fall arrest system unless another provision in paragraph (b) of this section provides for an alternative fall protection measure.   On or about December 7, 2023, Employees were exposed to fall hazards in excess of 10  feet while engaged in residential roofing activities. Fall protection was not being utilized while employees were engaged in roof installation and activities.  No abatement certification or documentation is required for this item.  Jose Luis Zaruma dba Z 1 Construction LLC was previously cited for a violation of this occupational safety and health standard or its equivalent standard 29 CFR 1926.102(a)(1), which was contained in OSHA inspection number 1524874, citation number 2, item number 1 and was affirmed as a final order on June 9, 2021, with respect to a workplace located at 621-633 LeParc Ct., Buffalo Grove, IL 60089.