OSHA Inspection: MALAN J. CONSTRUCTION INC.

Issued

Jul 9, 2025

Abate by

Jul 23, 2025

Penalty

Initial $4,965 · Current $2,483 Reduced

General-duty citation text

29 CFR  1926.501(b)(13):"Residential construction." Each employee engaged in residential construction activities 6 feet (1.8 m) or more above lower levels shall be protected by guardrail systems, safety net system, or personal fall arrest system unless another provision in paragraph (b) of this section provides for an alternative fall protection measure. Exception: When the employer can demonstrate that it is infeasible or creates a greater hazard to use these systems, the employer shall develop and implement a fall protection plan which meets the requirements of paragraph (k) of 1926.502.  On or about May 8, 2025, employees performing roofing operations were not protected from a fall , exposing employees to falls between 12-24 feet.   Abatement documentation is required of this item in accordance with the requirements of 29 CFR 1903.19(d).

Issued

Jul 9, 2025

Abate by

Jul 23, 2025

Penalty

Initial $3,547 · Current $1,774 Reduced

General-duty citation text

29 CFR  1926.1053(b)(1):When portable ladders are used for access to an upper landing surface, the ladder side rails shall extend at least 3 feet (.9 m) above the upper landing surface to which the ladder is used to gain access; or, when such an extension is not possible because of the ladder's length, then the ladder shall be secured at its top to a rigid support that will not deflect, and a grasping device, such as a grabrail, shall be provided to assist employees in mounting and dismounting the ladder. In no case shall the extension be such that ladder deflection under a load would, by itself, cause the ladder to slip off its support.  On or about May 8, 2025, employees used an extension ladder that was not three feet past the landing the accessed, exposing employees to a 12 foot fall.    Abatement documentation is required of this item in accordance with the requirements of 29 CFR 1903.19(d).

Issued

Jul 9, 2025

Abate by

Aug 27, 2025

Penalty

Initial $0 · Current $0

General-duty citation text

29 CFR  1926.503(b)(1):The employer shall verify compliance with paragraph (a) of this section by preparing a written certification record. The written certification record shall contain the name or other identity of the employee trained, the date(s) of the training, and the signature of the person who conducted the training or the signature of the employer. If the employer relies on training conducted by another employer or completed prior to the effective date of this section, the certification record shall indicate the date the employer determined the prior training was adequate rather than the date of actual training.  On or about May 8, 2025, employees engaged in roofing activities were exposed to fall hazards.  The employer failed to maintain a written certification record of fall protection training provided to employees.    Abatement certification is required for this item in accordance with 29 CFR 1903.19(c).