CHITTENANGO, NY —
OSHA Inspection: GRAY-SYRACUSE, INC.
Planned inspection · Safety discipline
At a glance
On , OSHA opened a planned safety inspection of GRAY-SYRACUSE, INC. in 901 E. GENESEE ST., CHITTENANGO, NY 13037 (NAICS 000000). OSHA activity number 106159387.
OSHA opens inspections for many reasons — routine scheduling under a national or local emphasis program, an employee complaint or referral, or a follow-up after a reported injury. Opening or conducting an inspection is not itself an allegation or a finding that this employer broke any rule; any findings appear as the citations listed below, and citations can be contested, reduced, or withdrawn.
Where did this inspection happen?
- Establishment
- GRAY-SYRACUSE, INC.
- Site address
- 901 E. GENESEE ST.
- City
- CHITTENANGO
- State
- NY
- ZIP
- 13037
What kind of inspection was it?
- Inspection type
- Planned (H)
- Scope
- Complete (A)
- Discipline
- Safety
- Advance notice
- No
- Union status
- N
When did the case open and close?
- Opened
- Closing conference
- Case closed
- Data loaded
Establishment context
- NAICS code
- 000000
- SIC code (legacy)
- 3324
- Employees
- 420
- Ownership type
- A
- Industry flags
- Manufacturing safety.
Citations
12 citations on file for this inspection.
5(a)(1)
- Issued
- Dec 23, 1997
- Abate by
- Dec 29, 1997
- Penalty
- Initial $1,700 · Current $1,020 Reduced
General-duty citation text
Section 5(a)(1) of the Occupational Safety and Health Act of 1970: The employer did not furnish employment and a place of employment which were free from recognized hazards that were causing or likely to cause death or serious physical harm to employees in that employees were exposed to the hazard of being struck by the load should the below-the-hook device fail. a)IN THE WORKPLACE, Gray-Syracuse, Chittennago NY, on or about 11-04- 97, the following below the hook, man made lifting devices, had no rated load markings, no operational test performed and no initial, frequent, or periodic inspections performed. 1)Foundry, pour area, overhead hoist with an under hook device for ladles. 2)Cut and Clean, Caustic area, P & H Crane with under hook device attached. Among other methods, several feasible and acceptable abatement methods to correct these hazards are to: 1)Prior to initial use, all new altered, modified or repaired lifting devices shall be inspected by a designated person and an operational test performed to verify compliance. 2)Mark the rated load of the lifting device on the main structure where it is visible. 3)Conduct frequent/ periodic inspections and perform the required maintenance following these inspections in accordance with ANSI B30.16-1987 Chapter 16-2.
Recent events (2)
- — I (S) $1020.00
- — Z (S) $1700.00
1910.106 E06 II
- Issued
- Dec 23, 1997
- Abate by
- Dec 29, 1997
- Penalty
- Initial $1,700 · Current $1,020 Reduced
Recent events (2)
- — I (S) $1020.00
- — Z (S) $1700.00
1910.132 D02
- Issued
- Dec 23, 1997
- Abate by
- Feb 25, 1998
- Penalty
- Initial $1,700 · Current $1,020 Reduced
Recent events (2)
- — I (S) $1020.00
- — Z (S) $1700.00
1910.132 F01
- Issued
- Dec 23, 1997
- Abate by
- Feb 25, 1998
Recent events (2)
- — I (S)
- — Z (S)
1910.184 E01
- Issued
- Dec 23, 1997
- Abate by
- Dec 29, 1997
- Penalty
- Initial $1,700 · Current $1,020 Reduced
Recent events (2)
- — I (S) $1020.00
- — Z (S) $1700.00
1910.184 E03 II
- Issued
- Dec 23, 1997
- Abate by
- Dec 29, 1997
Recent events (2)
- — I (S)
- — Z (S)
1910.212 A01
- Issued
- Dec 23, 1997
- Abate by
- Dec 29, 1997
- Penalty
- Initial $1,700 · Current $1,020 Reduced
Recent events (2)
- — I (S) $1020.00
- — Z (S) $1700.00
1910.215 B09
- Issued
- Dec 23, 1997
- Abate by
- Dec 29, 1997
Recent events (2)
- — I (S)
- — Z (S)
1910.213 B03
- Issued
- Dec 23, 1997
- Abate by
- Dec 29, 1997
- Penalty
- Initial $2,125 · Current $1,275 Reduced
Recent events (2)
- — I (S) $1275.00
- — Z (S) $2125.00
1910.305 J01 I
- Issued
- Dec 23, 1997
- Abate by
- Dec 29, 1997
- Penalty
- Initial $1,700 · Current $1,020 Reduced
Recent events (2)
- — I (S) $1020.00
- — Z (S) $1700.00
1910.22 D01
- Issued
- Dec 23, 1997
- Abate by
- Dec 29, 1997
Recent events (2)
- — I (O)
- — Z (O)
1910.212 B
- Issued
- Dec 23, 1997
- Abate by
- Dec 29, 1997
Recent events (2)
- — I (O)
- — Z (O)
More inspections at Gray-Syracuse, INC.
View Gray-Syracuse, INC.'s full OSHA safety record →
More inspections in this industry (NAICS 000000)
More inspections in NY
Source
This record is reproduced from the U.S. Department of Labor Open Data API (OSHA inspection dataset). The original IMIS detail view is available at OSHA's Establishment Search for activity number 106159387.
Look up any company's OSHA accident reports by company, or browse severe injury reports by year, state, and company.