WAKEFIELD, NE —
OSHA Inspection: MICHAEL FOODS EGG PRODUCTS CO
Planned inspection · Safety discipline
At a glance
On , OSHA opened a planned safety inspection of MICHAEL FOODS EGG PRODUCTS CO in 105 MAIN ST, WAKEFIELD, NE 68784 (NAICS 311615). OSHA activity number 311464796.
OSHA opens inspections for many reasons — routine scheduling under a national or local emphasis program, an employee complaint or referral, or a follow-up after a reported injury. Opening or conducting an inspection is not itself an allegation or a finding that this employer broke any rule; any findings appear as the citations listed below, and citations can be contested, reduced, or withdrawn.
Where did this inspection happen?
- Establishment
- MICHAEL FOODS EGG PRODUCTS CO
- Site address
- 105 MAIN ST
- City
- WAKEFIELD
- State
- NE
- ZIP
- 68784
What kind of inspection was it?
- Inspection type
- Planned (H)
- Scope
- Partial (B)
- Discipline
- Safety
- Advance notice
- No
- Union status
- N
When did the case open and close?
- Opened
- Closing conference
- Case closed
- Last modified
- Data loaded
Establishment context
- NAICS code
- 311615
- SIC code (legacy)
- 2015
- Employees
- 300
- Ownership type
- A
- Industry flags
- Manufacturing safety.
Citations
13 citations on file for this inspection.
5(a)(1)
- Issued
- Feb 2, 2009
- Abate by
- Feb 20, 2009
- Penalty
- Initial $6,300 · Current $3,150 Reduced
General-duty citation text
29 CFR 5(a)(1): of the Occupational Safety and Health Act of 1970: The employer did not furnish employment and a place of employment which were free from recognized hazards that were causing or likely to cause death or serious physical harm to employees in that employees are exposed to struck by hazards. In the Vat Room area located at 105 Main St Wakefield, NE 68784. - Employer is failing to ensure that pressurized piping used to moving egg products is monitored, guarded or provided with a pressure relief device. Among other methods, feasible and acceptable methods of abatement: 1) Monitor the pressurized system with gauges or over pressure sensors that can alert the operators/shut down the system. 2) Provided Guarding by either distance or shielding when there is a potential for a failure of a pressurized system. 3) Provide a means for pressure relief in the event of over pressurization. Pressure relief shall be located were employees are less likely to be exposed to this hazard. Abatement certification and abatement documentation is required for this violation. The documentation should include written verification of abatement, applicable measurements or monitoring results, and photographs or videos which you believe will be helpful. The abatement certification sheet is enclosed with the citations.
Recent events (2)
- — I (S) $3150.00
- — Z (S) $6300.00
1910.178 M05 I
- Issued
- Feb 2, 2009
- Abate by
- Feb 20, 2009
- Penalty
- Initial $1,350
Recent events (2)
- — I (S)
- — Z (S) $1350.00
1910.212 A01
- Issued
- Feb 2, 2009
- Abate by
- Feb 20, 2009
- Penalty
- Initial $1,350 · Current $1,350
Recent events (2)
- — I (S) $1350.00
- — Z (S) $1350.00
1910.215 B09
- Issued
- Feb 2, 2009
- Abate by
- Feb 20, 2009
- Penalty
- Initial $1,800 · Current $900 Reduced
Recent events (2)
- — I (S) $900.00
- — Z (S) $1800.00
1910.219 H01
- Issued
- Feb 2, 2009
- Abate by
- Feb 20, 2009
- Penalty
- Initial $2,250 · Current $1,125 Reduced
Recent events (2)
- — I (S) $1125.00
- — Z (S) $2250.00
1910.219 I02
- Issued
- Feb 2, 2009
- Abate by
- Feb 20, 2009
Recent events (2)
- — I (S)
- — Z (S)
1910.253 B04 III
- Issued
- Feb 2, 2009
- Abate by
- Feb 20, 2009
- Penalty
- Initial $1,800
Recent events (2)
- — I (O)
- — Z (S) $1800.00
1910.303 B01
- Issued
- Feb 2, 2009
- Abate by
- Feb 20, 2009
- Penalty
- Initial $1,800 · Current $1,800
Recent events (2)
- — I (S) $1800.00
- — Z (S) $1800.00
1910.303 B02
- Issued
- Feb 2, 2009
- Abate by
- Feb 20, 2009
- Penalty
- Initial $1,350
Recent events (2)
- — I (S)
- — Z (S) $1350.00
1910.303 G01 II
- Issued
- Feb 2, 2009
- Abate by
- Feb 20, 2009
- Penalty
- Initial $1,350 · Current $1,350
Recent events (2)
- — I (S) $1350.00
- — Z (S) $1350.00
1910.305 B01
- Issued
- Feb 2, 2009
- Abate by
- Feb 20, 2009
- Penalty
- Initial $1,800 · Current $1,800
Recent events (2)
- — I (S) $1800.00
- — Z (S) $1800.00
1910.305 G02 III
- Issued
- Feb 2, 2009
- Abate by
- Feb 20, 2009
- Penalty
- Initial $1,800
Recent events (2)
- — I (S)
- — Z (S) $1800.00
1904.32 B04 III
- Issued
- Feb 2, 2009
- Abate by
- Feb 20, 2009
Recent events (2)
- — I (O)
- — Z (O)
More inspections at Michael Foods EGG Products CO
View Michael Foods EGG Products CO's full OSHA safety record →
More inspections in this industry (NAICS 311615)
More inspections in NE
Source
This record is reproduced from the U.S. Department of Labor Open Data API (OSHA inspection dataset). The original IMIS detail view is available at OSHA's Establishment Search for activity number 311464796.
Look up any company's OSHA accident reports by company, or browse severe injury reports by year, state, and company.