MARIETTA, GA —
OSHA Inspection: WILLFAB, INC.
Planned inspection · Safety discipline
At a glance
On , OSHA opened a planned safety inspection of WILLFAB, INC. in 4648 CANTON ROAD, MARIETTA, GA 30066 (NAICS 332312). OSHA activity number 312777113.
OSHA opens inspections for many reasons — routine scheduling under a national or local emphasis program, an employee complaint or referral, or a follow-up after a reported injury. Opening or conducting an inspection is not itself an allegation or a finding that this employer broke any rule; any findings appear as the citations listed below, and citations can be contested, reduced, or withdrawn.
Where did this inspection happen?
- Establishment
- WILLFAB, INC.
- Site address
- 4648 CANTON ROAD
- City
- MARIETTA
- State
- GA
- ZIP
- 30066
- Mailing
- P. O. BOX 419, WOODSTOCK, GA 30188
What kind of inspection was it?
- Inspection type
- Planned (H)
- Scope
- Complete (A)
- Discipline
- Safety
- Advance notice
- No
- Union status
- N
When did the case open and close?
- Opened
- Closing conference
- Case closed
- Last modified
- Data loaded
Establishment context
- NAICS code
- 332312
- SIC code (legacy)
- 3441
- Employees
- 9
- Ownership type
- A
Citations
15 citations on file for this inspection.
5(a)(1)
- Issued
- Jun 1, 2010
- Abate by
- Jun 11, 2010
- Penalty
- Initial $750
General-duty citation text
Section 5(a)(1) of the Occupational Safety and Health Act of 1970: The employer did not furnish to each of his employees employment and a place of employment which were free from recognized hazards that were causing or likely to cause death or serious physical harm to employees in that employees were exposed to being struck by moving or falling suspended load: a) Paint area on or about February 22, 2010. - Employees were exposed to being struck by suspended loads as the actuator buttons on the pendant controls of overhead under- slung hoists were not marked as to indicate the direction of travel that was controlled by each button. b) Fabrication area on or about February 22, 2010. - Employees were exposed to be by suspended loads as the actuator buttons on the pendant controls of overhead under- slung hoists were not marked as to indicate the direction of travel that was controlled by each button. ABATEMENT DOCUMENTATION AND CERTIFICATION IS REQUIRED Among other methods, feasible and acceptable methods to correct the hazardous condition may include: Following the requirements The American Society of Mechanical Engineers safety standard for cableways, cranes, derricks, hoists, hooks, jacks, and slings, ASME B30.16, chapter 16, section 16-1.1.2.
Recent events (2)
- — I (S)
- — Z (S) $750.00
5(a)(1)
- Issued
- Jun 1, 2010
- Abate by
- Jun 11, 2010
- Penalty
- Initial $750 · Current $375 Reduced
General-duty citation text
Section 5(a)(1) of the Occupational Safety and Health Act of 1970: The employer did not furnish to each of his employees employment and a place of employment which were free from recognized hazards that were causing or likely to cause death or serious physical harm to employees in that employees were exposed to employees were exposed to being struck by moving or falling suspended loads: a) Paint area on or about February 22, 2010. - The overhead under slung cranes had not been inspected on a routine, annual, basis to determine if any deficiencies are present that could present a hazard to employees. b) Fabrication area on or about February 22, 2010. - The overhead under slung cranes had not been inspected on a routine, annual, basis to determine if any deficiencies are present that could present a hazard to employees. ABATEMENT DOCUMENTATION AND CERTIFICATION IS REQUIRED Among other methods, feasible and acceptable methods to correct the hazardous condition may include: Following the requirements of the latest revision of the ASME standard for Monorails and Underhung Cranes, ASME B30.11.
Recent events (2)
- — I (S) $375.00
- — Z (S) $750.00
1910.36 D01
- Issued
- Jun 1, 2010
- Abate by
- Jun 4, 2010
- Penalty
- Initial $750 · Current $375 Reduced
Recent events (2)
- — I (S) $375.00
- — Z (S) $750.00
1910.107 G02
- Issued
- Jun 1, 2010
- Abate by
- Jun 11, 2010
- Penalty
- Initial $750 · Current $375 Reduced
Recent events (2)
- — I (S) $375.00
- — Z (S) $750.00
1910.147 C01
- Issued
- Jun 1, 2010
- Abate by
- Jun 11, 2010
- Penalty
- Initial $1,500 · Current $750 Reduced
Recent events (2)
- — I (S) $750.00
- — Z (S) $1500.00
1910.178 L01 I
- Issued
- Jun 1, 2010
- Abate by
- Jun 11, 2010
- Penalty
- Initial $750 · Current $375 Reduced
Recent events (2)
- — I (S) $375.00
- — Z (S) $750.00
1910.212 A01
- Issued
- Jun 1, 2010
- Abate by
- Jun 11, 2010
- Penalty
- Initial $1,500 · Current $750 Reduced
Recent events (2)
- — I (S) $750.00
- — Z (S) $1500.00
1910.253 B05 IIG
- Issued
- Jun 1, 2010
- Abate by
- Jun 4, 2010
- Penalty
- Initial $1,500 · Current $750 Reduced
Recent events (2)
- — I (S) $750.00
- — Z (S) $1500.00
1910.305 B02 I
- Issued
- Jun 1, 2010
- Abate by
- Jun 11, 2010
- Penalty
- Initial $450 · Current $225 Reduced
Recent events (2)
- — I (S) $225.00
- — Z (S) $450.00
1910.305 C04
- Issued
- Jun 1, 2010
- Abate by
- Jun 11, 2010
- Penalty
- Initial $750 · Current $375 Reduced
Recent events (2)
- — I (S) $375.00
- — Z (S) $750.00
1910.334 A02 II
- Issued
- Jun 1, 2010
- Abate by
- Jun 11, 2010
- Penalty
- Initial $1,500 · Current $750 Reduced
Recent events (2)
- — I (S) $750.00
- — Z (S) $1500.00
1904.32 A02
- Issued
- Jun 1, 2010
- Abate by
- Jun 11, 2010
1904.32 A04
- Issued
- Jun 1, 2010
- Abate by
- Jun 11, 2010
1910.37 B02
- Issued
- Jun 1, 2010
- Abate by
- Jun 7, 2010
1910.37 B05
- Issued
- Jun 1, 2010
- Abate by
- Jun 7, 2010
More inspections at Willfab, INC.
View Willfab, INC.'s full OSHA safety record →
More inspections in this industry (NAICS 332312)
More inspections in GA
Source
This record is reproduced from the U.S. Department of Labor Open Data API (OSHA inspection dataset). The original IMIS detail view is available at OSHA's Establishment Search for activity number 312777113.
Look up any company's OSHA accident reports by company, or browse severe injury reports by year, state, and company.