OSHA Inspection: AUTUMN VIEW GARDENS

Issued

Apr 8, 2014

Abate by

May 23, 2014

Penalty

Initial $2,550 · Current $1,785 Reduced

General-duty citation text

29 CFR 1910.147(c)(1): The employer did not establish a program consisting of an energy control procedure, employee training and periodic inspections to ensure that before any employee performed any servicing or maintenance on a machine or equipment where the unexpected energizing, startup or release of stored energy could occur and cause injury, the machine or equipment shall be isolated from the energy source and rendered inoperative  a/ At the facility for maintenance employee(s) who performed servicing or maintenance on equipment including but not limited to GFI outlets, a written lockout tag out program had not been developed.

Issued

Apr 8, 2014

Abate by

May 23, 2014

Penalty

Initial $0 · Current $0

General-duty citation text

29 CFR 1910.147(d)(3)  All energy isolating devices that are needed to control the energy to the machine or equipment were not physically located and operated in such a manner as to isolate the machine or equipment from the energy source(s):  For the maintenance employee who repaired GFI outlets without locking out the circuit breaker or equivalent.

Issued

Apr 8, 2014

Abate by

Jul 8, 2014

Penalty

Initial $0 · Current $0

General-duty citation text

29 CFR 1910.212(a)(1):  One or more methods of machine guarding was not provided to protect the operator and other employees in the machine area from hazards such as those created by rotating parts:  In the kitchen, for cooks who used the HOBART A-200 mixer (SN #11-125-141) to mix brownies and cake mix without a guard for the rotating parts.

Issued

Apr 8, 2014

Abate by

May 23, 2014

Penalty

Initial $0 · Current $0

General-duty citation text

29 CFR 1910.305(g)(2)(iii):  Flexible cords and cables were not connected to devices and fittings so that strain relief was provided that will prevent pull from being directly transmitted to joints or terminal screws:    In the kitchen the cord and plug belonging to the HOBART A-200 (SN # 11-125-141) mixer lacked strain relief.

Issued

Apr 8, 2014

Abate by

May 23, 2014

Penalty

Initial $2,550 · Current $1,785 Reduced

General-duty citation text

29 CFR 1910.151(c): Where the eyes or body of any person may be exposed to injurious corrosive materials, suitable facilities for quick drenching or flushing of the eyes and body were not provided within the work area for immediate emergency use:  In the kitchen, for employees who used GREASESTRIP PLUS to clean ovens and LIME-A-WAY, an approved eyewash with a continual upright stream of water was not available for immediate emergency use.

Issued

Apr 8, 2014

Abate by

May 23, 2014

Penalty

Initial $2,550 · Current $1,785 Reduced

General-duty citation text

29 CFR 1910.1030(f)(1)(ii) (D): The employer shall ensure that all medical evaluations and procedures including the hepatitis B vaccine and vaccination series and post-exposure evaluation and follow-up, including prophylaxis, are provided according to recommendations of the U.S. Public Health Service current at the time these evaluations and procedures take place, except as specified by this paragraph (f):  At the facility, for employee(s) with ongoing daily use of sharps including but not limited to certified medical technicians, antibody testing was not provided within 1-2 months after completion of the Hepatitis B vaccination series of three shots: