GLEN CARBON, IL —
OSHA Inspection: JOHN BEAL INC.
Planned inspection · Safety discipline
At a glance
On , OSHA opened a planned safety inspection of JOHN BEAL INC. in 613 BRIARSTONE DRIVE, GLEN CARBON, IL 62034 (NAICS 238160). OSHA activity number 342187739.
OSHA opens inspections for many reasons — routine scheduling under a national or local emphasis program, an employee complaint or referral, or a follow-up after a reported injury. Opening or conducting an inspection is not itself an allegation or a finding that this employer broke any rule; any findings appear as the citations listed below, and citations can be contested, reduced, or withdrawn.
Where did this inspection happen?
- Establishment
- JOHN BEAL INC.
- Site address
- 613 BRIARSTONE DRIVE
- City
- GLEN CARBON
- State
- IL
- ZIP
- 62034
- Mailing
- 12181 PRICHARD FARM ROAD, MARYLAND HEIGHTS, MO 63043
What kind of inspection was it?
- Inspection type
- Planned (H)
- Scope
- Partial (B)
- Discipline
- Safety
- Advance notice
- No
- Union status
- B
When did the case open and close?
- Opened
- Closing conference
- Case closed
- Last modified
- Data loaded
Establishment context
- NAICS code
- 238160
- Employees
- 6
- Ownership type
- A
Citations
5 citations on file for this inspection.
1926.102 A01
- Issued
- Apr 10, 2017
- Abate by
- May 5, 2017
- Penalty
- Initial $5,070 · Current $2,079 Reduced
General-duty citation text
29 CFR 1926.102(a)(1): Eye and face protective equipment were not used when machines or operations presented potential eye or face injury from physical, chemical, or radiation agents: Eye protective equipment was not used when employees were exposed to eye injury while using pneumatic nail guns.
Recent events (3)
- — F (S) $2079
- — C (S) $5070
- — Z (S) $5070
1926.152 D04
- Issued
- Apr 10, 2017
- Abate by
- May 5, 2017
- Penalty
- Initial $6,338 · Current $0 Reduced
General-duty citation text
29 CFR 1926.152(d)(4): At least one portable fire extinguisher having a rating of not less than 20B:C units was not provided on all vehicles used for transporting and/or dispensing flammable or combustible liquids: The employer did not ensure that a portable fire extinguisher was available to employees who were carrying a five (5) gallon gasoline can in the vehicle. The gasoline was being used to fill the air compressor.
Recent events (3)
- — F (S) $0
- — C (S) $6338
- — Z (S) $6338
1926.501 B13
- Issued
- Apr 10, 2017
- Abate by
- May 5, 2017
- Penalty
- Initial $8,873 · Current $5,767 Reduced
General-duty citation text
29 CFR 1926.501(b)(13): Each employee engaged in residential construction activities 6 feet (1.8 m) or more above lower levels was not protected by guardrail systems, safety net systems, personal fall arrest systems, or an alternative fall protection measure under another provision of paragraph 1926.501 (b), nor did the employer demonstrate that it is infeasible or creates a greater hazard to use these systems and develop and implement a fall protection plan which meets the requirements of paragraph (k) of section 1926.502: The employer did not ensure fall protection was implemented during residential construction operations when workers were exposed to the hazard of falling up to approximately eleven (11) feet off the roof eve when they were installing asphalt roofing shingles.
Recent events (3)
- — F (S) $5767
- — C (S) $8873
- — Z (S) $8873
1926.502 D15
- Issued
- Apr 10, 2017
- Abate by
- May 5, 2017
- Penalty
- Initial $8,873 · Current $0 Reduced
General-duty citation text
29 CFR 1926.502(d)(15): Anchorage points used for attachment of personal fall arrest equipment were not independent of any anchorage point being used to support or suspend platforms and capable of supporting at least 5,000 pounds (22.2 kN) per employee: The employer did not ensure fall protection anchor points were installed to support at least 5,000 pounds for employees who were exposed to the hazard of falling approximately eleven (11) feet while performing roofing activities.
Recent events (3)
- — F (S) $0
- — C (S) $8873
- — Z (S) $8873
1926.502 D06 III
- Issued
- Apr 10, 2017
- Abate by
- May 5, 2017
- Penalty
- Initial $8,873 · Current $0 Reduced
General-duty citation text
29 CFR 1926.502(d)(6)(iii): A snaphook not of the locking type was engaged to a Dee-ring to which another snaphook or other connector is attached: The employer did not ensure that anchor points only had one lifeline snaphook attached to them.
Recent events (3)
- — F (S) $0
- — C (S) $8873
- — Z (S) $8873
More inspections at John Beal INC.
View John Beal INC.'s full OSHA safety record →
More inspections in this industry (NAICS 238160)
More inspections in IL
Source
This record is reproduced from the U.S. Department of Labor Open Data API (OSHA inspection dataset). The original IMIS detail view is available at OSHA's Establishment Search for activity number 342187739.
Look up any company's OSHA accident reports by company, or browse severe injury reports by year, state, and company.