RANTOUL, IL —
OSHA Inspection: RANTOUL FOODS
Complaint inspection · Safety discipline
At a glance
On , OSHA opened a complaint safety inspection of RANTOUL FOODS in 205 TURNER DR, RANTOUL, IL 61866 (NAICS 311611). OSHA activity number 342450079.
OSHA opens inspections for many reasons — routine scheduling under a national or local emphasis program, an employee complaint or referral, or a follow-up after a reported injury. Opening or conducting an inspection is not itself an allegation or a finding that this employer broke any rule; any findings appear as the citations listed below, and citations can be contested, reduced, or withdrawn.
Where did this inspection happen?
- Establishment
- RANTOUL FOODS
- Site address
- 205 TURNER DR
- City
- RANTOUL
- State
- IL
- ZIP
- 61866
- Mailing
- 205 TURNER DR, RANTOUL, IL 61866
What kind of inspection was it?
- Inspection type
- Complaint (B)
- Scope
- Partial (B)
- Discipline
- Safety
- Advance notice
- No
- Union status
- B
When did the case open and close?
- Opened
- Closing conference
- Case closed
- Last modified
- Data loaded
Establishment context
- NAICS code
- 311611
- Employees
- 480
- Ownership type
- A
Citations
4 citations on file for this inspection.
1910.30 A01
- Issued
- Oct 27, 2017
- Abate by
- Nov 21, 2017
- Penalty
- Initial $5,432 · Current $2,000 Reduced
General-duty citation text
29 CFR 1910.30(a)(1): Before any employee is exposed to a fall hazard, the employer did not provide training for each employee who uses personal fall protection systems or who is required to be trained as specified elsewhere in this subpart. Employers must ensure employees are trained in the requirements of this paragraph on or before May 17, 2017: On or about June 29, 2017, Employees were required to wear fall protection, and the employer did not ensure employees were trained on or before May 17, 2017, on the following topics: (i) The nature of the fall hazards in the work area and how to recognize them; (ii) The procedures to be followed to minimize those hazards; (iii) The correct procedures for installing, inspecting, operating, maintaining, and disassembling the personal fall protection systems that the employee uses; and (iv) The correct use of personal fall protection systems and equipment specified in paragraph (a)(1) of this section, including, but not limited to, proper hook-up, anchoring, and tie-off techniques, and methods of equipment inspection and storage, as specified by the manufacturer.
Recent events (2)
- — I (O) $2000
- — Z (S) $5432
1910.37 A03
- Issued
- Oct 27, 2017
- Abate by
- Nov 21, 2017
- Penalty
- Initial $7,243 · Current $0 Reduced
General-duty citation text
29 CFR 1910.37(a)(3): Exit routes were not maintained free and unobstructed so that no materials or equipment were placed, either permanently or temporarily, within the exit route: On or about June 29, 2017, Employees working in and around the freezer area were exposed to fire, smoke inhalation, slips, trips and falls hazards in the event of an emergency because the door were obstructed with conveyors lines.
Recent events (2)
- — I (S) $0
- — Z (S) $7243
1910.37 B02
- Issued
- Oct 27, 2017
- Abate by
- Nov 21, 2017
- Penalty
- Initial $0 · Current $5,000
General-duty citation text
29 CFR 1910.37(b)(2): Each exit was not clearly visible and marked by a sign reading "Exit": On or about June 29, 2017, Employees working in and around the freezer area were exposed to fire, smoke inhalation, slips, trips and falls hazards in the event of an emergency because the exit doors in the freezer were not marked with an exit sign.
Recent events (2)
- — I (S) $5000
- — Z (S) $0
1910.28 B01 I
- Issued
- Oct 27, 2017
- Abate by
- Nov 14, 2017
- Penalty
- Initial $36,215 · Current $5,000 Reduced
General-duty citation text
29 CFR 1910.28(b)(1)(i): The employer did not ensure that each employee on a walking-working surface with an unprotected side or edge that was 4 feet (1.2 m) or more above a lower level was protected from falling by one or more of the following: Guardrail systems, safety net systems, or personal fall arrest systems: On or about June 29, 2017, An employee working on the bunger platform was exposed to a fall hazard because the area was not protected by a standard railing, safety net systems, or personal fall arrest system. Rantoul Foods was previously cited for a violation of this occupational safety and health standard or its equivalent standard 1910.23(c)(1), which was contained in OSHA inspection number 950535 citation number 1, item number 2, and was affirmed as a final order on January 21, 2014, with respect to a workplace located at 205 Turner Drive, Rantoul, IL, 61866.
Recent events (2)
- — I (R) $5000
- — Z (R) $36215
More inspections at Rantoul Foods
View Rantoul Foods's full OSHA safety record →
More inspections in this industry (NAICS 311611)
More inspections in IL
Source
This record is reproduced from the U.S. Department of Labor Open Data API (OSHA inspection dataset). The original IMIS detail view is available at OSHA's Establishment Search for activity number 342450079.
Look up any company's OSHA accident reports by company, or browse severe injury reports by year, state, and company.