SPRINGFIELD, IL —
OSHA Inspection: COUNTY MATERIALS CORP.
Complaint inspection · Health discipline
At a glance
On , OSHA opened a complaint health inspection of COUNTY MATERIALS CORP. in 2917 NORTH DIRKSEN PARKWAY, SPRINGFIELD, IL 62702 (NAICS 327332). OSHA activity number 348283912.
What this inspection record means
OSHA opens inspections for many reasons — routine scheduling under a national or local emphasis program, an employee complaint or referral, or a follow-up after a reported injury. Opening or conducting an inspection is not itself an allegation or a finding that this employer broke any rule; any findings appear as the citations listed below, and citations can be contested, reduced, or withdrawn.
Watch County Materials Corp. — free
Get an email when a new federal OSHA severe-injury report for County Materials Corp. is published. One employer, no account, unsubscribe in one click.
Where did this inspection happen?
- Establishment
- COUNTY MATERIALS CORP.
- Site address
- 2917 NORTH DIRKSEN PARKWAY
- City
- SPRINGFIELD
- State
- IL
- ZIP
- 62702
- Mailing
- 2310 N 40TH ST, WISCONSIN RAPIDS, WI 54494
What kind of inspection was it?
- Inspection type
- Complaint (B)
- Scope
- Partial (B)
- Discipline
- Health
- Advance notice
- No
- Union status
- B
When did the case open and close?
- Opened
- Closing conference
- Case closed
- Last modified
- Data loaded
Establishment context
- NAICS code
- 327332
- Employees
- 37
- Ownership type
- A
Citations
11 citations on file for this inspection.
1910.22 A01
- Issued
- Oct 21, 2025
- Abate by
- Nov 25, 2025
- Penalty
- Initial $14,187 · Current $0 Reduced
General-duty citation text
29 CFR 1910.22(a)(1): The employer did not ensure that all places of employment, passageways, storerooms, service rooms, and walking-working surfaces are kept in a clean, orderly, and sanitary condition: On or about June 3, 2025, employees working in the Hawkeye Department were exposed to slips and falls because the employer did not ensure the floor was kept free from accumulating dust, dirt, and debris.
Recent events (2)
- — I (S) $0
- — Z (S) $14187
1910.1053 H01
- Issued
- Oct 21, 2025
- Abate by
- Nov 25, 2025
- Penalty
- Initial $0 · Current $0
General-duty citation text
29 CFR 1910.1053(h)(1): The employer allowed dry sweeping or dry brushing where such activity could contribute to employee exposure to respirable crystalline silica and wet sweeping, HEPA-filtered vacuuming or other methods that minimize the likelihood of exposure were feasible: On or about June 3, 2025, employees working in the Hawkeye Department were exposed to respirable crystalline silica and the employer allowed dry sweeping.
Recent events (2)
- — I (S) $0
- — Z (S) $0
1910.1053 H02 I
- Issued
- Oct 21, 2025
- Abate by
- Nov 25, 2025
- Penalty
- Initial $0 · Current $0
General-duty citation text
29 CFR 1910.1053(h)(2)(i): The employer allowed compressed air to be used to clean clothing or surfaces where such activity could contribute to employee exposure to respirable crystalline silica without being used in conjunction with a ventilation system to capture blown dust: On or about June 3, 2025, employees working in the Hawkeye Department were exposed to respirable crystalline silica and the employer allowed compressed air to be used to blow the chute of the mixer.
Recent events (2)
- — I (S) $0
- — Z (S) $0
1910.25 B03
- Issued
- Oct 21, 2025
- Abate by
- Dec 17, 2025
- Penalty
- Initial $14,187 · Current $8,512 Reduced
General-duty citation text
29 CFR 1910.25(b)(3): The employer did not ensure that stairs have uniform riser heights and tread depths between landings: On or about June 3, 2025, employees were exposed to trip and fall hazards while utilizing the ship stairs leading to the basement of the boxing area in the Hawkeye Department in order to hook up the vibrators and perform cleaning activities and the employer did not ensure that the ship stairs have uniform riser heights and tread depths between landings.
Recent events (2)
- — I (S) $8512.2
- — Z (S) $14187
1910.25 B08
- Issued
- Oct 21, 2025
- Abate by
- Dec 17, 2025
- Penalty
- Initial $0 · Current $0
General-duty citation text
29 CFR 1910.25(b)(8): The employer did not ensure that spiral, ship, or alternating tread-type stairs are used only when the employer can demonstrate that it is not feasible to provide standard stairs: On or about June 3, 2025 employees were exposed to trip and fall hazards while utilizing the ships stairs leading to the basement of the boxing area in the Hawkeye Department in order to hook up the vibrators and perform cleaning activities and the employer did not ensure that standard stairs were used.
Recent events (2)
- — I (S) $0
- — Z (S) $0
1910.28 B11 III
- Issued
- Oct 21, 2025
- Abate by
- Dec 17, 2025
- Penalty
- Initial $0 · Current $0
General-duty citation text
29 CFR 1910.28(b)(11)(iii): The employer did not ensure that each ship stairs and alternating tread type stairs is equipped with handrails on both sides: On or about June 3, 2025, employees were exposed to trip and fall hazards while utilizing the ship stairs leading to the basement of the boxing area in the Hawkeye Department in order to hook up the vibrators and perform cleaning activities and the employer did not ensure that the ship stairs were equipped with handrails on both sides.
Recent events (2)
- — I (S) $0
- — Z (S) $0
1910.28 B01 I
- Issued
- Oct 21, 2025
- Abate by
- Dec 17, 2025
- Penalty
- Initial $16,550 · Current $9,930 Reduced
General-duty citation text
29 CFR 1910.28(b)(1)(i): Except as provided elsewhere in this section, the employer must ensure that each employee on a walking-working surface with an unprotected side or edge that is 4 feet (1.2 m) or more above a lower level is protected from falling by one or more of the following: On or about June 3, 2025, employees working in the Hawkeye Department were exposed to fall hazards: a. greater than 10 feet while working from the north side of the square boxing area because a section of the interior guardrail was missing. b. greater than 10 feet while working from the catwalk located on the north side of the square boxing area because there is no guardrail located on the exterior side of the catwalk. c. greater than 10 feet while working from the catwalk located on the south side of the square boxing area because there is no guardrail located on the exterior side of the catwalk. d. greater than 10 feet while working from the east side of the square boxing area because an approximately 78 inch section of the exterior guardrail was missing. e. greater than 10 feet while working from the catwalk located on the east side of the square boxing area because there is no guardrail located on the exterior side of the catwalk. f. greater than 10 feet while working from the catwalk located on the west side of the square boxing area because there is no guardrail located on the exterior side of the catwalk. g. greater than 10 feet while working from the west side of the square boxing area because an approximately 42 inch section of the interior guardrail was missing. h. greater than four feet while performing cleaning activities from the catwalk around the concrete mixer because there is an unprotected floor opening located on the south side of the mixer. i. greater than four feet while performing cleaning activities from inside the concrete mixer because there is an unprotected floor opening located above the dumpster.
Recent events (2)
- — I (S) $9930
- — Z (S) $16550
1910.29 B01
- Issued
- Oct 21, 2025
- Abate by
- Nov 25, 2025
- Penalty
- Initial $0 · Current $0
General-duty citation text
29 CFR 1910.29(b)(1): The top edge height of top rails, or equivalent guardrail system members, are 42 inches (107 cm), plus or minus 3 inches (8 cm), above the walking-working surface: On or about June 3, 2025, employees working in the Hawkeye Department were exposed to fall hazards: a. greater than 10 feet while working from the north side of the round boxing area because the top rail was approximately 29.5 inches above the walking-working surface. b. greater than 10 feet while working from the south side of the round boxing area because the top rail was approximately 29 inches above the walking-working surface. c. greater than 10 feet while working from the east side of the round boxing area because the top rail was approximately 29 inches above the walking-working surface. d. greater than 10 feet while working from the west side of the round boxing area because the top rail was approximately 28.5 inches above the walking-working surface. e. greater than 10 feet while working from the north side of the square boxing area because the interior top rail was approximately 20 inches above the catwalk. f. greater than 10 feet while working from the north side of the square boxing area because the exterior top rail was approximately 36 inches above the walking-working surface. g. greater than 10 feet while working from the left side of the south side of the square boxing area because the exterior top rail was approximately 35 inches above the walking-working surface. h. greater than 10 feet while working from the east side of the square boxing area because the interior top rail was approximately 46 inches above the catwalk. i. greater than 10 feet while working from the west side of the square boxing area because the interior top rail was approximately 30 inches above the catwalk. j. greater than 10 feet while working from the west side of the square boxing area because the exterior top rail was approximately 36.5 inches above the walking-working surface.
Recent events (2)
- — I (S) $0
- — Z (S) $0
1910.29 B02 I
- Issued
- Oct 21, 2025
- Abate by
- Dec 17, 2025
- Penalty
- Initial $0 · Current $0
General-duty citation text
29 CFR 1910.29(b)(2)(i): Midrails were not installed at a height midway between the top edge of the guardrail system and the walking-working surface: On or about June 3, 2025, employees working in the Hawkeye Department were exposed to fall hazards: a. greater than 10 feet while working from the north side of the round boxing area because the midrail was approximately 12 inches above the walking-working surface. b. greater than 10 feet while working from the south side of the round boxing area because the midrail was approximately 11.5 inches above the walking-working surface. c. greater than 10 feet while working from the east side of the round boxing area because the midrail was approximately 12 inches above the walking-working surface. d. greater than 10 feet while working from the west side of the round boxing area because the midrail was approximately 11 inches above the walking-working surface. e. greater than 10 feet while working from the north side of the square boxing area because the interior midrail was 5.5 inches above the walking-working surface. f. greater than 10 feet while working from the south side of the square boxing area because the interior midrail was approximately 22 inches above the catwalk. g. greater than 10 feet while working from the left side of the south side of the square boxing area because the exterior midrail was approximately 18 inches above the walking-working surface. h. greater than 10 feet while working from the middle of the south side of the square boxing area because the exterior midrail was approximately 26 inches above the walking-working surface. i. greater than 10 feet while working from the right side of the south side of the square boxing area because the exterior midrail was approximately 23.5 inches above the walking-working surface. j. greater than 10 feet while working from the east side of the square boxing area because the interior midrail was approximately 25 inches above the catwalk. k. greater than 10 feet while working from the east side of the square boxing area because the exterior midrail was approximately 23 inches above the walking-working surface. l. greater than 10 feet while working from the west side of the square boxing area because the interior midrail was approximately 13 inches above the catwalk.
Recent events (2)
- — I (S) $0
- — Z (S) $0
1910.212 A01
- Issued
- Oct 21, 2025
- Penalty
- Initial $11,823 · Current $7,094 Reduced
General-duty citation text
29 CFR 1910.212(a)(1): One or more methods of machine guarding was not provided to protect the operator and other employees in the machine area from hazards such as those created by point of operation, ingoing nip points, rotating parts, flying chips and sparks: On or about June 3, 2025, employees working in the Hawkeye Department were exposed to amputation hazards while checking the consistency of the concrete from the catwalk located around the concrete mixer because the mixer door located on the west side of the mixer is continually left open.
Recent events (2)
- — I (S) $7093.8
- — Z (S) $11823
1910.303 B07 I
- Issued
- Oct 21, 2025
- Penalty
- Initial $7,093 · Current $0 Reduced
General-duty citation text
29 CFR 1910.303(b)(7)(i): Unused openings in boxes, raceways, auxiliary gutters, cabinets, equipment cases, or housings were not effectively closed to afford protection substantially equivalent to the wall of the equipment: On or about June 3, 2025, employees working in the basement of the boxing area were exposed to electrical hazards while hooking up the vibrators and performing cleaning activities because there were unused openings in the electrical cabinet.
Recent events (2)
- — I (O) $0
- — Z (S) $7093
More inspections at County Materials Corp.
Feb 7, 2023
MARATHON, WI
Oct 28, 2021
MARATHON, WI
Oct 27, 2021
MARATHON, WI
Nov 4, 2020
JANESVILLE, WI
Nov 28, 2018
GREEN BAY, WI
View County Materials Corp.'s full OSHA safety record →
More inspections in this industry (NAICS 327332)
May 18, 2026
Rinker Materials LLC · BILLINGS, MT
May 5, 2026
NEW South Construction · ATLANTIC BEACH, FL
May 4, 2026
WA317991042 - Spokane Wilbert Vault CO · SPOKANE, WA
Apr 6, 2026
WA317990611 - Spokane Wilbert Vault CO · SPOKANE, WA
Feb 18, 2026
Rinker Materials · GREENFIELD, IN
More inspections in IL
Jul 17, 2026
Quantum Technical Services INC. · FRANKFORT, IL
Jul 17, 2026
Augustana College · ROCK ISLAND, IL
Jul 17, 2026
Sunrun Installation Services, INC. · WASHINGTON, IL
Jul 17, 2026
Conservation of Sculpture & Objects Studio, INC. · FOREST PARK, IL
Jul 17, 2026
Proflow Pumping Solutions · BLUE ISLAND, IL
Source
This record is reproduced from the U.S. Department of Labor Open Data API (OSHA inspection dataset). The original IMIS detail view is available at OSHA's Establishment Search for activity number 348283912.
Look up any company's OSHA accident reports by company, or browse severe injury reports by year, state, and company.