OSHA Inspection: MAIN LINE CONTRACTOR CORPORATION

Issued

Jun 30, 2023

Abate by

Jul 27, 2023

Penalty

Initial $4,465 · Current $4,465

General-duty citation text

29 CFR 1910.178(l)(1)(i): The employer did not ensure that each powered industrial truck operator is competent to operate a powered industrial truck safely, as demonstrated by the successful completion of the training and evaluation specified in this paragraph (l) as incorporated by reference under 1926.602(d):  a) 37, 39, 41, 43, 45 & 47 Stanton Road, Mount Holly NJ: The employer did not ensure that the company worksite Foreman, who utilized a Lull All-Terrain lift  at the worksite, had received training which included formal instruction, hands on and an evaluation with a written certification of completion, on or about 02/15/23.  NOTE: IN ADDITION TO ABATEMENT CERTIFICATION, THE EMPLOYER IS REQUIRED TO SUBMIT ABATEMENT DOCUMENTATION FOR THIS ITEM. FAILURE TO COMPLY WILL RESULT IN AN ADDITIONAL PENALTY OF $1000.00 IN ACCORDANCE WITH 29 CFR 1903.19.

Issued

Jun 30, 2023

Penalty

Initial $2,678 · Current $2,678

General-duty citation text

29 CFR 1926.416(e)(1): Worn or frayed electric cords or cables were used:  a- 41 & 43 Stanton Road, Mount Holly NJ: On or about  02/15/23 portable electric circular saws, in use by the workers and company worksite Foreman, were observed being powered with flexible cords whose outer coverings were damaged.

Issued

Jun 30, 2023

Abate by

Jul 7, 2023

Penalty

Initial $6,250 · Current $6,250

General-duty citation text

29 CFR 1926.1053(b)(5)(i): Non-self-supporting ladders were not used at an angle such than the horizontal distance from the top support to the foot of the ladder was approximately one-quarter of the working length of the ladder (the distance along the ladder between the foot and the top support):  a- 37, 39, 41, 43, 45 & 47 Stanton Road, Mount Holly NJ: A company worker was exposed to fall hazards up to and in excess of 20 feet 7 inches to the ground surface below when utilizing an aluminum extension ladder whose rise to run ratio was not 4 to 1 and, as such, did not have an angle of approximately 75 degrees from the horizontal .  Condition observed on or about 02/15/23.  NOTE: IN ADDITION TO ABATEMENT CERTIFICATION, THE EMPLOYER IS REQUIRED TO SUBMIT ABATEMENT DOCUMENTATION FOR THIS ITEM.  FAILURE TO COMPLY WILL RESULT IN AN ADDITIONAL PENALTY OF $1000.00 IN ACCORDANCE WITH 29 CFR 1903.19.

Issued

Jun 30, 2023

Abate by

Jul 7, 2023

Penalty

Initial $5,358 · Current $5,358

General-duty citation text

29 CFR  1926.1053(b)(11): Ladder(s) was/were moved, shifted, or extended while occupied:   a- 37, 39, 41, 43, 45 & 47 Stanton Road, Mount Holly NJ: On or about 02/15/23 the company worksite Foreman and a worker were exposed to fall hazards, up to and in excess of 6 feet to the ground surface below, when occupying the ladder's lower rungs while extending these aluminum extension ladders in order to lower their extended fly sections.    NOTE: IN ADDITION TO ABATEMENT CERTIFICATION, THE EMPLOYER IS REQUIRED TO SUBMIT ABATEMENT DOCUMENTATION FOR THIS ITEM.  FAILURE TO COMPLY WILL RESULT IN AN ADDITIONAL PENALTY OF $1000.00 IN ACCORDANCE WITH 29 CFR 1903.19.

Issued

Jun 30, 2023

Abate by

Jul 7, 2023

Penalty

Initial $6,250 · Current $6,250

General-duty citation text

29 CFR  1926.1053(b)(22): Employees  using ladders were carrying objects or loads that could cause the employee to lose balance and fall:   a- 37, 39, 41, 43, 45 & 47 Stanton Road, Mount Holly NJ: On or about 02/15/23 the company worksite Foreman and a worker were exposed to fall hazards, up to and in excess of 20 feet 7 inches to the ground surface below, when climbing up extension ladders while carrying a 4 foot by 8 foot (or cut to certain lengths and widths) single piece of OSB plywood sheathing with one of their hands used to climb the ladder.    NOTE: IN ADDITION TO ABATEMENT CERTIFICATION, THE EMPLOYER IS REQUIRED TO SUBMIT ABATEMENT DOCUMENTATION FOR THIS ITEM.  FAILURE TO COMPLY WILL RESULT IN AN ADDITIONAL PENALTY OF $1000.00 IN ACCORDANCE WITH 29 CFR 1903.19.

Issued

Jun 30, 2023

Abate by

Jul 7, 2023

Penalty

Initial $53,573 · Current $53,573

General-duty citation text

29 CFR 1926.102(a)(1): The employer did not ensure that each affected employee used appropriate eye or face protection when exposed to eye or face hazards from flying particles.  a- 37, 39, 41, 43, 45 & 47 Stanton Road, Mount Holly NJ: While using air nailers and portable electric circular saws when engaged in sheathing activities, workers and the company worksite Foreman were exposed to eye loss and eye injury as eye/face protection was not being utilized. Condition observed on or about 02/15/23.  NOTE: IN ADDITION TO ABATEMENT CERTIFICATION, THE EMPLOYER IS REQUIRED TO SUBMIT ABATEMENT DOCUMENTATION FOR THIS ITEM. FAILURE TO COMPLY WILL RESULT IN AN ADDITIONAL PENALTY OF $1000.00 IN ACCORDANCE WITH 29 CFR 1903.19.

Issued

Jun 30, 2023

Abate by

Jul 7, 2023

Penalty

Initial $62,504 · Current $62,504

General-duty citation text

29 CFR  1926.501(b)(13): Each employee(s) engaged in residential construction activities 6 feet (1.8 m) or more above lower levels were not protected by guardrail systems, safety net system, or personal fall arrest system, nor were employee(s) provided with an alternative fall protection measure under another provision of paragraph 1926.501 (b):   a- Roof Of Structure - 37, 39, 41, 43, 45 & 47 Stanton Road, Mount Holly NJ: On or about 02/14/23 workers were not protected from falling when walking and working from pitched roofs while wearing full body harnesses that were not connected to anchors with lanyards or other approved means .  As such, these workers were exposed to fall hazards up to and in excess of 25 feet to the ground surface below.   b- Back Roof of Structure - 37, 39, 41, 43, 45 & 47 Stanton Road, Mount Holly NJ:  On or about 02/15/23 a worker was not protected from falling when walking and working from pitched roofs while wearing a full body harness that were not connected to an anchor with a lanyard or other approved means .  As such, this worker was exposed to fall hazards up to and in excess of 25 feet to the ground surface below.   c- Front Roof of Structure -37, 39, 41, 43, 45 & 47 Stanton Road, Mount Holly NJ:  On or about 02/15/23 a worker was not protected from falling when wearing a full body harness whose connected lanyard's other end was  NOT connected to an anchor.  As such, this worker was exposed to fall hazards up to and in excess of 25 feet to the ground surface below.   NOTE: IN ADDITION TO ABATEMENT CERTIFICATION, THE EMPLOYER IS REQUIRED TO SUBMIT ABATEMENT DOCUMENTATION FOR THIS ITEM. FAILURE TO COMPLSULTY WILL RE IN AN ADDITIONAL PENALTY OF $1000.00 IN ACCORDANCE WITH 29 CFR 1903.19.