OSHA Inspection: LESS ESTIMATE CONSTRUCTION LLC

Issued

Nov 17, 2023

Penalty

Initial $3,349 · Current $3,349

General-duty citation text

29 CFR  1926.100(a):Employees working in areas where there is a possible danger of head injury from impact, or from falling or flying objects, or from electrical shock and burns, shall be protected by protective helmets.  On or about October 10, 2023 the employer failed to ensure employees working in the active area below a residential roofing project were protected from struck-by injuries.  The employer did not ensure employees were utilizing a hard hat to protect from head injuries.  No abatement documentation is required for this item.

Issued

Nov 17, 2023

Abate by

Dec 18, 2023

Penalty

Initial $9,375 · Current $9,375

General-duty citation text

29 CFR  1926.501(b)(13):"Residential construction." Each employee engaged in residential construction activities 6 feet (1.8 m) or more above lower levels shall be protected by guardrail systems, safety net system, or personal fall arrest system unless another provision in paragraph (b) of this section provides for an alternative fall protection measure. Exception: When the employer can demonstrate that it is infeasible or creates a greater hazard to use these systems, the employer shall develop and implement a fall protection plan which meets the requirements of paragraph (k) of 1926.502.  On or about October 10, 2023 the employer did not ensure that employees who were engaged in residential construction activities were protected from fall hazards.   Employees were exposed to falls of approximately 10 feet to the ground below while performing roofing activities.  Abatement documentation is required for this item in accordance with 29 CFR 1903.19(d).  Less Estimate Construction LLC was previously cited for a violation of this occupational safety and health standard or its equivalent standard1926.501(b)(13), which was contained in OSHA inspection number 1412367, citation number 1, item number 1 and was affirmed as a final order on January 30, 2020, with respect to a workplace located at 8740-48 Golden Rose 8702-08 Trinity Drive Tinley Park, IL 60478.

Issued

Nov 17, 2023

Abate by

Dec 18, 2023

Penalty

Initial $6,697 · Current $6,697

General-duty citation text

29 CFR  1926.1053(b)(1):When portable ladders are used for access to an upper landing surface, the ladder side rails shall extend at least 3 feet (.9 m) above the upper landing surface to which the ladder is used to gain access; or, when such an extension is not possible because of the ladder's length, then the ladder shall be secured at its top to a rigid support that will not deflect, and a grasping device, such as a grabrail, shall be provided to assist employees in mounting and dismounting the ladder. In no case shall the extension be such that ladder deflection under a load would, by itself, cause the ladder to slip off its support.  On or about October 10, 2023 the employer failed to ensure the ladder used to access and egress the residential roof was 3 foot above the landing edge.  The ladder that is being used by the employees that were conducting residential roofing activities did not extend 3 feet above the landing edge.    Abatement documentation is required for this item in accordance with 29 CFR 1903.19(d).  Less Estimate Construction LLC was previously cited for a violation of this occupational safety and health standard or its equivalent standard 1926.1053(b)(1), which was contained in OSHA inspection number 1357579, citation number 1, item number 1 and was affirmed as a final order on April 23, 2019, with respect to a workplace located at 5181 Falcon Rd. Rockford, IL 61101.

Issued

Nov 17, 2023

Abate by

Dec 18, 2023

Penalty

Initial $0 · Current $0

General-duty citation text

29 CFR  1926.503(b)(1):The employer shall verify compliance with paragraph (a) of this section by preparing a written certification record. The written certification record shall contain the name or other identity of the employee trained, the date(s) of the training, and the signature of the person who conducted the training or the signature of the employer. If the employer relies on training conducted by another employer or completed prior to the effective date of this section, the certification record shall indicate the date the employer determined the prior training was adequate rather than the date of actual training.  On or about October 10, 2023 the employer failed to certify that employees had been trained to recognize and minimize fall hazards. Employees were exposed to fall hazards in excess of 11feet while performing roofing activities on a residential structure without using fall protection.   Abatement documentation is required for this item in accordance with 29 CFR 1903.19(d).